Manuel d'utilisation / d'entretien du produit U39-LP1 du fabricant Regency
Aller à la page of 44
W ARNING: If the information in these instructions are not followed exactly , a fi re or explosion may result causing property damage, personal injury or loss of life. FOR YOUR SAFETY Do not store or use gasoline or other fl ammable vapors and liquids in the vicinity of this or any other appliance.
2 Regency ® U39 UL TIMA TE Direct V ent Freestanding Gas Stove REGENCY ® UL TIMA TE Direct V ent Freestanding Gas Stove T o the New Owner: Congratulations! Y ou are the owner of a state-of-the-art UL TIMA TE Direct V ent Gas Stove by FPI Fireplace Products International Ltd.
Regency ® U39 UL TIMA TE Direct V ent Freestanding Gas Stove 3 T ABLE OF CONTENTS SAFETY LABEL Copy of Safety Label ..................................................... 4 REQUIREMENTS MA Code - CO Detector ...........................................
4 Regency ® U39 UL TIMA TE Direct V ent Freestanding Gas Stove This is a copy of the label that accompanies each UL TIMA TE Direct V ent Freestanding Gas Stove. We have printed a copy of the contents here for your review . The safety SAFETY LABEL label is located on the inside of the drop down pedestal door .
Regency ® U39 UL TIMA TE Direct V ent Freestanding Gas Stove 5 REQUIREMENTS 5.08: Modifica tions to NFPA-54, Chapter 10 (2) Revise 10.8. 3 by adding the follow ing additiona l requirements: (a) For a.
6 Regency ® U39 UL TIMA TE Direct V ent Freestanding Gas Stove IMPORT ANT MESSAGE SA VE THESE INSTRUCTIONS The UL TIMA TE Direct V ent Freestanding Gas Stove must be installed in accordance with these instructions. Carefully read all the instructions in this manual fi rst.
Regency ® U39 UL TIMA TE Direct V ent Freestanding Gas Stove 7 INST ALLA TION 8) Any safety glass removed for servicing must be replaced prior to operating the appliance. 9) T o prevent injury , do not allow anyone who is unfamiliar with the operation to use the fi replace.
8 Regency ® U39 UL TIMA TE Direct V ent Freestanding Gas Stove For V ent T ermination requirements, see "Exterior V ent termination Locations" section. LOUVER INST ALLA TION 1) Attach the top & bottom louvers to the side stove panel using 2 screws per side.
Regency ® U39 UL TIMA TE Direct V ent Freestanding Gas Stove 9 EXTERIOR VENT TERMINAL LOCA TIONS A = Clearance above grade, veranda, porch, deck, or balcony *(min. 12"/30cm) B= Clearance to window or door that may be opened *(12"/30cm) C= Clearance to permanently closed window *(min.
10 Regency ® U39 UL TIMA TE Direct V ent Freestanding Gas Stove 4” X 6-5/8” RIGID PIPE CROSS REFERENCE CHART Components from different Manufacturers may not be mixed.
Regency ® U39 UL TIMA TE Direct V ent Freestanding Gas Stove 11 Description Simpson Direct V ent Pro ® Simpson Direct V ent GS ® Discontinued Selkirk Direct-T emp™ American Metal Products ® Amer.
12 Regency ® U39 UL TIMA TE Direct V ent Freestanding Gas Stove RIGID PIPE VENTING SYSTEMS Horizontal or V ertical Terminations Alternate Horizontal T er- mination Caps INST ALLA TION This product ha.
Regency ® U39 UL TIMA TE Direct V ent Freestanding Gas Stove 13 INST ALLA TION PRECAUTIONS These venting systems are engineered products that have been designed and tested for use with the U39-NG1, and U39-LP1.
14 Regency ® U39 UL TIMA TE Direct V ent Freestanding Gas Stove Horizontal V enting with T wo (2) 90 o Elbows Option V H + H1 A) 3' Min. 2' Max. B) 5' Min. 3' Max. C) 8' Min. 4' Max. With these options, maximum total pipe length is 30 feet with minimum of 8 feet total vertical and maximum 4 feet total horizontal.
Regency ® U39 UL TIMA TE Direct V ent Freestanding Gas Stove 15 INST ALLA TION DV ST OVE HORIZONT AL VENT KIT INST ALLA TION Minimum Installation Height: U39: 59-3/4" ( 1518mm) DV ST OVE HORIZONT AL VENT KIT (# 946-1 16 & #946-216) DV Stove Horizontal V ent Kit (2 ft.
16 Regency ® U39 UL TIMA TE Direct V ent Freestanding Gas Stove INST ALLA TION Note: if the centerline cannot be met, the adjustable sections will have to be cut. e) Cut the 2 ft. or 4 ft. section of rigid pipe to length. Ensure that the pipe length when cut will seat onto both the starter collar and the 90 o elbow .
Regency ® U39 UL TIMA TE Direct V ent Freestanding Gas Stove 17 Alternate Horizontal T ermination Caps Dura-V ent Basic Horizontal Kit # 970 1 90 o Elbow 1 W all Thimble Cover 1 Horiz.
18 Regency ® U39 UL TIMA TE Direct V ent Freestanding Gas Stove NOTE: For Snorkel terminations in ABOVE grade installations, follow national or local code requirements.
Regency ® U39 UL TIMA TE Direct V ent Freestanding Gas Stove 19 Diagram 10 Diagram 9 Diagram 8 Diagram 7 Diagram 6 7) Install the Wall Thimble in the center of the 10" square and attach with wood screws. 8) Slide the decorative wall thimble up to the wall surface being careful not to scratch the paint and attach with screws provided.
20 Regency ® U39 UL TIMA TE Direct V ent Freestanding Gas Stove INST ALLA TION Diagram 1 1: The upper half of the fl ashing is installed under the roofi ng material and not nailed down until the chimney is installed. This allows for small adjustments.
Regency ® U39 UL TIMA TE Direct V ent Freestanding Gas Stove 21 INST ALLA TION Using a level, make sure the support is vertical. If the support extends above the roof, cut it fl ush with the top of the roof. Nail the support to the frame opening using (8) 3" spiral nails or #8 x 1-1/2" screws.
22 Regency ® U39 UL TIMA TE Direct V ent Freestanding Gas Stove Converting a Masonry Chimney Important: The existing masonry flue opening needs to have an area of at least a 36 sq.
Regency ® U39 UL TIMA TE Direct V ent Freestanding Gas Stove 23 U39-NG1: For 0 to 2000 feet altitude U39-LP1: For 0 to 4500 feet altitude Burner Inlet Orifi ce Sizes: Natural Gas Propane Burner #32 #50 Max. Input - Natural Gas/Propane 38,000 Btu/h Min.
24 Regency ® U39 UL TIMA TE Direct V ent Freestanding Gas Stove CONVERSION KIT# 731-969 FROM NG T O LP THIS CONVERSION MUST BE DONE BY A QUALIFIED GAS FITTER IF IN DOUBT DO NOT DO THIS CONVERSION !! 1) Shut off the gas supply . 2) Open the front door and carefully remove the logs and lava rock.
Regency ® U39 UL TIMA TE Direct V ent Freestanding Gas Stove 25 16) Pull off the pilot cap to expose the pilot orifi ce. 17) Unscrew the pilot orifi ce with the allen key and replace with the LPG pilot orifi ce in the kit. 19) Reinstall new burner orifi ce LPG stamped #50 and tighten.
26 Regency ® U39 UL TIMA TE Direct V ent Freestanding Gas Stove 7) Reversing step 2 and secure the control panel back onto the stove pedestal with the screws. 9) The Ground Wire, DC Sparker Ignition Wire and Piezo Spark Wire all go through the hole located on the pedestal back cover .
Regency ® U39 UL TIMA TE Direct V ent Freestanding Gas Stove 27 GAS PIPE PRESSURE TESTING The appliance must be isolated from the gas supply piping system by closing its individual manual shut-off valve during any pressure testing of the gas supply piping system at test pressures equal to or less than 1/2 psig.
28 Regency ® U39 UL TIMA TE Direct V ent Freestanding Gas Stove AERA TION ADJUSTMENT The burner aeration is factory set but may need adjusting due to either the local gas supply or altitude.
Regency ® U39 UL TIMA TE Direct V ent Freestanding Gas Stove 29 LOG SET INST ALLA TION INST ALLA TION Embers Embers The "02" refer numbers (i.e. 02-65) are molded into the rear of each log. Note: Install Optional Brick Panels prior to installing logs.
30 Regency ® U39 UL TIMA TE Direct V ent Freestanding Gas Stove Cutout Pin D)02-46 B)02-56 A)02-65 7) Place the Left T op Log D)02-46 on the pin on Log B)02-56 and on top of the cutout on Log A)02-65. E)02-45 C)02-44 8) Place Front Right Log E)02-45 on the two pins as shown.
Regency ® U39 UL TIMA TE Direct V ent Freestanding Gas Stove 31 Cutout Notch F)02-47 E)02-45 A)02-65 11 ) Place the notch in Center Log F)02-47 over Log E)02-45 and across the cutout on Log A)02- 65.
32 Regency ® U39 UL TIMA TE Direct V ent Freestanding Gas Stove WIRING DIAGRAM CAUTION: Label all wires prior to disconnection when servicing controls.
Regency ® U39 UL TIMA TE Direct V ent Freestanding Gas Stove 33 14 GA. 16 GA. 18 GA. 20 GA. 22 GA. 50 Ft. 32 Ft. 20 Ft. 12 Ft. 9 Ft. Recommended Maximum Lead Length (T wo-Wire) When Using W all Thermostat (CP-2 System) Wire Size Max. Length Thermostat Wire T able OPTIONAL W ALL THERMOST A T A wall thermostat may be installed if desired.
34 Regency ® U39 UL TIMA TE Direct V ent Freestanding Gas Stove OPERA TING INSTRUCTIONS SHUTDOWN INSTRUCTIONS 1) Use the Burner ON/OFF switch, thermostat or remote control to turn off the burner . 2) Push in the PILOT knob slightly and turn clockwise to off.
Regency ® U39 UL TIMA TE Direct V ent Freestanding Gas Stove 35 1) Push in gas control knob slightly and turn to “PILOT” position. 2) Push in control knob all the way and hold in until the pilot lights up. Continue to hold the control knob in for about 20 seconds after the pilot is lit.
36 Regency ® U39 UL TIMA TE Direct V ent Freestanding Gas Stove MAINTENANCE MAINTENANCE INSTRUCTIONS 1) Always turn off the valve before cleaning. For relighting, refer to lighting instructions. Keep the burner and control compartment clean by brushing and vacuuming at least once a year .
Regency ® U39 UL TIMA TE Direct V ent Freestanding Gas Stove 37 Mitred Glass Replacement Removing Glass 1) Remove the door from the unit and place on a soft surface to prevent scratching. 2) Pull out the door gasket. 3) Remove the 24 nuts holding the glass retainers in place.
38 Regency ® U39 UL TIMA TE Direct V ent Freestanding Gas Stove MAINTENANCE F AN MAINTENANCE If your fan requires maintenance or replacement, access to the fan is through the plate on the rear wall of the fi rebox. NOTE: the unit MUST NOT be operated without the fan access panel securely in place and correctly sealed.
Regency ® U39 UL TIMA TE Direct V ent Freestanding Gas Stove 39 REMOVING V AL VE 2) Undo the six screws holding the control panel in place. 3) Disconnect all wires from the back of the panel and then remove panel. Y ou should lay the panel on a soft cloth so it doesn't get marked up.
40 Regency ® U39 UL TIMA TE Direct V ent Freestanding Gas Stove P ARTS LIST 30) 630-021 Fan Access Panel 31) 730-019 Rear Panel 32) 730-565 Firebox Baffl e/Restrictor Assy 33) 630-520 False T op Ass.
Regency ® U39 UL TIMA TE Direct V ent Freestanding Gas Stove 41 BURNER & LOG ASSEMBL Y 51) 910-241 Burner ON/OFF Switch (3-way) 52) 910-190 Piezo Ignitor & Nut 53) 904-586 Knob for Fan Speed .
42 Regency ® U39 UL TIMA TE Direct V ent Freestanding Gas Stove P ARTS LIST DOOR ASSEMBLIES Part # Description 730-923 Brush Nickel Mitred Door - Complete 730-924 Gold Mitred Door - Complete 730-926 .
Regency ® U39 UL TIMA TE Direct V ent Freestanding Gas Stove 43 W ARRANTY Regency Fireplace Products are designed with reliability and simplicity in mind. In addition, our internal Quality Assurance T e am carefully inspects each unit thoroughly before it leaves our facility .
Installer: Please complete the following information Dealer Name & Address: ______________________________________________ ___________________________________________________________________ Insta.
Un point important après l'achat de l'appareil (ou même avant l'achat) est de lire le manuel d'utilisation. Nous devons le faire pour quelques raisons simples:
Si vous n'avez pas encore acheté Regency U39-LP1 c'est un bon moment pour vous familiariser avec les données de base sur le produit. Consulter d'abord les pages initiales du manuel d'utilisation, que vous trouverez ci-dessus. Vous devriez y trouver les données techniques les plus importants du Regency U39-LP1 - de cette manière, vous pouvez vérifier si l'équipement répond à vos besoins. Explorant les pages suivantes du manuel d'utilisation Regency U39-LP1, vous apprendrez toutes les caractéristiques du produit et des informations sur son fonctionnement. Les informations sur le Regency U39-LP1 va certainement vous aider à prendre une décision concernant l'achat.
Dans une situation où vous avez déjà le Regency U39-LP1, mais vous avez pas encore lu le manuel d'utilisation, vous devez le faire pour les raisons décrites ci-dessus,. Vous saurez alors si vous avez correctement utilisé les fonctions disponibles, et si vous avez commis des erreurs qui peuvent réduire la durée de vie du Regency U39-LP1.
Cependant, l'un des rôles les plus importants pour l'utilisateur joués par les manuels d'utilisateur est d'aider à résoudre les problèmes concernant le Regency U39-LP1. Presque toujours, vous y trouverez Troubleshooting, soit les pannes et les défaillances les plus fréquentes de l'apparei Regency U39-LP1 ainsi que les instructions sur la façon de les résoudre. Même si vous ne parvenez pas à résoudre le problème, le manuel d‘utilisation va vous montrer le chemin d'une nouvelle procédure – le contact avec le centre de service à la clientèle ou le service le plus proche.
