Manuel d'utilisation / d'entretien du produit 530 du fabricant Weber
Aller à la page of 36
W E B E R W E B E R SPIRIT ™ 530 Series LP Gas Barbecue Owner’ s Manual National Association PROPANE GAS ® 92694 11/98 Serial Number Please use this number in registering your w arranty and any correspondence with the f actory . W ARNING 1. Do not store spare LP Cylinder within 10 feet (3m) of this appliance.
D ANGER Failure to f ollo w the Dangers, W arnings and Cautions contained in this Owner’ s Manual may result in serious bodil y injur y or death, or in a fire or an explosion causing damage to property . W ARNINGS Do not store a spare or disconnected LP tank under or near this barbecue.
3 W eber-Stephen Products Co. (W eber) hereby warr ants to the ORIGINAL PURCHASER of this W eber Gas Barbecue that it will be free of def ects in mater ial and workmanship from the date of purchase as.
© 1998 W eber . W eber , , Flav orizer and Crossov er are registered U .S. trademarks; Spirit, Gas Catcher , FlameCheck, and Spider Stopper are U .S. trademarks of W eber-Stephen Products Co ., 200 East Daniels Road, P alatine, IL 60067-6266. U .S.A.
5 Contents WARNINGS ................................................................ 2 W arranty & P atents .................................................. 3-4 General Instructions .................................................... 6 Assembly .
6 General Instructions Y our W eber Gas Barbecue is a por table outdoor cooking appliance. With the W eber Gas Barbecue you can grill, barbecue, roast and bak e with results that are difficult to duplicate with indoor kitchen appliances. The closed lid and Flav or izer Bars produce that "outdoor" fla v or in the food.
7 Step 1 Check pac kage contents Cooking bo x (assembly) Lid (assembly) LP tank Bottom tra y T wo cooking grates LP tank filler adapter Control panel Assembl y T ools needed Hammer 7/16 open-end or an adjustable wrench Pliers Block of w ood Phillips screwdriv er Supplies needed Y our LP tank is shipped empty f or saf ety .
Left frame Right frame Wheel frame Leg frame F rame connector W ork table Accessor y rack W ar ming rack Five Fla vorizer Bars T ank panel assembly F ront panel Catch pan holder Catch pan T wo dr ip p.
T wo plastic buttons (actual size) T wo 1/4-20 wing nuts (actual size) Ele v en 1/4 inch nylon w ashers T wo hair pin cotters T wo wheel hubcaps 1/4-20 keps n ut T wo phillips screws/washers Check con.
10 Figure 1 W E B E R W E B E R Figure 2 Leg tabs F rame tabs (a) (b) Right frame Left frame Step 2 Assemble wheel fr ame Y ou will need: wheel frame, tw o wheels , tw o wheel hubcaps , hammer and a bloc k of wood. Set one end of wheel frame on the b lock of w ood (or other hard, protected surf ace).
11 Figure 3 Figure 4 Figure 5 View from rear of barbecue Dimples to the inside Fuel scale decal Plastic buttons Step 5 Install tubing plugs Y ou will need: two tubing plugs and a hammer . Inser t tubing plugs into the ends of the leg frame.Figure 4. T o fully seat the plugs, you ma y hav e to tap them lightly with a hammer .
Guide screw (a) (b) (c) Wing Nuts View from behind cooking bo x Figure 8 12 Figure 6 Burner tubes F rame brace (a) (b) Spacer brac ket K eps nut Ta b F rame cross piece Nylon washer Bolt Slide the cooking bo x to the left within the frame. Put the washer on the bolt.
F rame brace Manif old brack et 13 Figure 9 Figure 10 Figure 11 F rame connector Cross brace T ank panel tabs Slots in frame brace F rame brace Step 8 Install manif old brack et Y ou will need: manif old brac ket Hook the brac ket onto the manif old at approximately the center of the length of the manif old.
14 Figure 12 View from front right View from front left F E F E Figure 13 Igniter lock n ut Small par t of keyhole in frame brace F rame brace F rame brace K eyhole in frame brace (a) (b) (c) Step 10 Add fuel scale assembly Y ou will need: fuel scale assembly , two 1/4-20 wing nuts and two nylon w ashers.
15 F E F E F E Figure 14 T ank lock wing nut (a) (b) Scale setting wing nut Step 12 Set LP fuel scale Y ou will need: LP tank (empty). Note - F or accuracy , the fuel scale must be set with an empty tank. W e utilize v ar ious LP tank manuf acturers. Some of the tanks we receiv e have diff er ing top collar assemblies .
16 Figure 17 T ur n so regulator vent does not collect water Hose T ank lock wing nut Quick disconnect engaged V alve handwheel close clockwise T ank valv e Collar Male fitting Pressure relief valv e T ank Regulator Regulator vent (a) (b) (c) Figure 16 Figure 15 F E Step 15 Connect LP tank W ARNING: Make sure that the LP tank valve is closed.
17 Figure 18 (a) Figure 19 (c) (d) (b) W ARNING: Y ou should check f or gas leaks every time you disconnect and reconnect a gas fitting. Note - All f actor y made connections hav e been thoroughly check ed for gas leaks . The burners hav e been flame tested.
18 Figure 20 Figure 21 Figure 23 Figure 22 Figure 24 Bottom tra y Finger grip on front edge of bottom tra y Finger grip F ront side of catch pan holder Step 17 Install Flav orizer Bars and Cooking Grates Y ou will need: five Fla vorizer Bars and two cooking g rates.
19 Hair pin cotter Hinge pin Figure 25 Figure 26 T ool holders Inser t in frame brace Control panel Phillips screws/ washers (a) (b) Step 19 Install Lid Y ou will need: lid, two hinge pins and two hair pin cotters . Set the lid in place. Align the hinges at the rear of the barbecue.
20 Step 21 Complete accessor y installation Y ou will need: work table , accessor y rack, w ar ming rack, f our tubing plugs and thermometer . Set the accessor y rack across the bottom br aces in front of the frame connector . Figure 27 (a). Open the lid and set the warming rack into the slots at the rear of the cooking bo x.
21 1 3 2 4 7 6 8 5 Figure 1 Crosso ver Ignition System OPERA TING INSTR UCTIONS Lighting Summar y lighting instructions are on the control panel. D ANGER Failure to open lid while igniting the bar.
22 1 3 2 4 5 8 6 7 Figure 2 Manual Lighting Manual Lighting 4) T ur n the tank on by turning the tank valv e counterclockwise . 5) Str ike a match and put the flame into the matchlight hole in the front of the cooking bo x. W ARNING: Do not lean over open barbecue.
23 Cooking W ARNING: Do not move the W eber Gas Barbecue when operating or hot. Y ou can adjust the FRONT and BA CK burners as desired. The control settings High (H), Medium (M), Low (L), or Off (O) are described in your W eber cookbook. The cookbook uses these notations to describe the settings of the FRONT and BA CK b urners.
24 Scale setting wing nut T ank lock wing nut T ank valv e Collar (a) (b) Figure 3 Figure 4 Refilling the LP tank W e recommend that y ou refill before the scale indicator reaches "E".
25 Figure 6 Male fitting Regulator Collar Quick disconnect engaged Figure 5 (a) (b) c) Connect the hose to the tank. Route the hose so it does not interf ere with the scale indicator rod. Slide back the collar of the quic k disconnect on the tank valv e.
26 26 Safe handling tips f or LP Gas ■ Liquid Propane (LP) gas is a petroleum product as are gasoline and natural gas. LP gas is a gas at regular temperatures and pressures. Under moder ate pressure, inside a cylinder , LP gas is a liquid. As the pressure is released the liquid readily vaporizes and becomes gas.
Annual Maintenance After a period of nonuse we recommend that you perf or m the f ollowing maintenance procedures f or y our safety . W ARNING: Check hose bef ore each use of barbecue for nic ks, cracking, abrasions or cuts. If the hose is found to be d ama ged i n a ny wa y , do not use the barbecue.
28 Burner inside cooking bo x Figure 11 Dark blue Light blue Tips occasionally yello wish Figure 9 V entur i Air shutter V entur i fin W eber Spider Stopper Guard Figure 10 Flames Figure 12 Figure 13 .
29 e) Remov e the manifold brac ket and unscrew the tw o wing nuts that hold the manif old to the cooking box. Pull the manif old and v alve assemb ly out of the burners and carefully set it down.
30 30 Figure 20 White wire Black wire C A UTION : If the Spider Stopper Guards do not fit tightly , contact Weber -Stephen Customer Ser vice . W ARNING: Af ter r ei ns ta lling the gas lines, they should be leak chec ked with a soap and water solution before using the barbecue.
Prob lem Burners b urn with a yello w or orange flame, in conjunction with the smell of gas. Burners do not light. -or - Burners ha ve a small flickering flame in the HIGH position. -or- Barbecue temperature only reaches 250˚ to 300˚ degrees in the HIGH position.
32 W E B E R W E B E R 3 1 2 4 5 6 9 7 8 14-15 18 19 16 49 50 51 38 31 39 40 41 42 43 44-45 46 36 34 33 32 31 29 28 27 47-48 37 35 20 21 22 30 10 11 12 13 17 23 24 25 26 ® ® ® ® ® ® ® ®.
33 1 Hair Pin Cotters (2) 2 Hinge pins (2) 3 Left Endcap 4 Shroud (Assembly) 5 Lid Handle 6 W ar ming rack 7 Flav or izer bars (5) 8 Cooking grates (2) 9 W ork table 10 T ubing plugs (8) 11 1/4-20 x 2.
.
.
A F INAL W ORD OF T HANKS hank you for choosing a W eber Barbecue. Our family here at W eber has worked hard to produce the highest quality products for your satisfaction.
Un point important après l'achat de l'appareil (ou même avant l'achat) est de lire le manuel d'utilisation. Nous devons le faire pour quelques raisons simples:
Si vous n'avez pas encore acheté Weber 530 c'est un bon moment pour vous familiariser avec les données de base sur le produit. Consulter d'abord les pages initiales du manuel d'utilisation, que vous trouverez ci-dessus. Vous devriez y trouver les données techniques les plus importants du Weber 530 - de cette manière, vous pouvez vérifier si l'équipement répond à vos besoins. Explorant les pages suivantes du manuel d'utilisation Weber 530, vous apprendrez toutes les caractéristiques du produit et des informations sur son fonctionnement. Les informations sur le Weber 530 va certainement vous aider à prendre une décision concernant l'achat.
Dans une situation où vous avez déjà le Weber 530, mais vous avez pas encore lu le manuel d'utilisation, vous devez le faire pour les raisons décrites ci-dessus,. Vous saurez alors si vous avez correctement utilisé les fonctions disponibles, et si vous avez commis des erreurs qui peuvent réduire la durée de vie du Weber 530.
Cependant, l'un des rôles les plus importants pour l'utilisateur joués par les manuels d'utilisateur est d'aider à résoudre les problèmes concernant le Weber 530. Presque toujours, vous y trouverez Troubleshooting, soit les pannes et les défaillances les plus fréquentes de l'apparei Weber 530 ainsi que les instructions sur la façon de les résoudre. Même si vous ne parvenez pas à résoudre le problème, le manuel d‘utilisation va vous montrer le chemin d'une nouvelle procédure – le contact avec le centre de service à la clientèle ou le service le plus proche.
