Manuel d'utilisation / d'entretien du produit CDVR33N/PV7;N/PE7;N/PSC7 du fabricant Monessen Hearth
Aller à la page of 68
.
CDV SC7 & C D V7 Se ries Gas F ir e place 69D301 1 .
CDV SC7 & C D V7 Se ries Gas F ir e place 69D301 1 3 4. Never install the fireplace • in a recreational vehicle • where curtains, furniture, clothing, or other flam- mable objects are less than 4" from the front, top, or sides of the fireplace • in high traffic areas • in windy or drafty areas 5.
CDV SC7 & C D V7 Se ries Gas F ir e place 4 69D301 1 1. Do not use this fireplace to cook food or burn paper or other objects. 13. Never place anything on top of fireplace.
CDV SC7 & C D V7 Se ries Gas F ir e place 69D301 1 5 • This appliance has been certified for use with either natural or propane gas.
CDV SC7 & C D V7 Se ries Gas F ir e place 6 69D301 1 Inpu t ratin gs are shown in BTU per hour and are cer tified without deration for elevations up to 4,500 feet (1,370 m) above sea level.
CDV SC7 & C D V7 Se ries Gas F ir e place 69D301 1 7 Figure 2 - CDVR Series Fireplace Dimensions G F H.
CDV SC7 & C D V7 Se ries Gas F ir e place 8 69D301 1 G F H A J C R D E 1 56M ” 15/16” Q - Minimum .
CDV SC7 & C D V7 Se ries Gas F ir e place 69D301 1 9 Read this homeowner manual thoroughly and follow all instructions carefully .
CDV SC7 & C D V7 Se ries Gas F ir e place 10 69D301 1 Plan for the installation of your appliance. This includes determining where the unit is to be installed, the vent conf igurati on to be used, framing and fini shing details, and wheth er any optional accessor ies (i.
CDV SC7 & C D V7 Se ries Gas F ir e place 69D301 1 1 1 .
CDV SC7 & C D V7 Se ries Gas F ir e place 1 69D301 1 The fi rep lac e m ust be se cur ed to th e floor and/or to framing studs as shown in Figure 7 . Use two () wood screws or masonry/ concrete screws to secure fireplace to the floor . Use four (4) screws to attach fireplace to framing.
CDV SC7 & C D V7 Se ries Gas F ir e place 69D301 1 13 Consult local building codes before beginning the installation. The installer must make sure to select the proper vent system for installation.
CDV SC7 & C D V7 Se ries Gas F ir e place 14 69D301 1 V V V V V V V X X X D E B B B C B M B A J .
CDV SC7 & C D V7 Se ries Gas F ir e place 69D301 1 15 Outside Corner Inside Corner T ermination Clearances T ermination clearances for buildings with combustible and noncombustible exteriors.
CDV SC7 & C D V7 Se ries Gas F ir e place 16 69D301 1 When using twist lock pipe it is not necessary to use seal- ant on the joints.
CDV SC7 & C D V7 Se ries Gas F ir e place 69D301 1 17 The V ent Graph should be read in conjunction with the following vent installation instructions to determine the re- lationship between the vertical and horizontal dimensions of the vent system.
CDV SC7 & C D V7 Se ries Gas F ir e place 18 69D301 1 3" 1" 1" 1" FP2288 TV rear vent Figure 14 - Combustible Clearances for V ent Pipe A Mi nimu m of 3" Cle ara nce to the T op Is Required Along Horizontal Length until Flue Pipe Penetrates Outside W all.
CDV SC7 & C D V7 Se ries Gas F ir e place 69D301 1 19 When installed as a rear vent unit this appliance may be vented directly to a termination located on the rear wall behind the appliance.
CDV SC7 & C D V7 Se ries Gas F ir e place 0 69D301 1 FP2294 Side View Vent Termination 1/25/00 djt Finish W all.
CDV SC7 & C D V7 Se ries Gas F ir e place 69D301 1 1 • The maximum number of 90° elbows per side wall in- stallation is three (3). Figure 21 • If a 90° elbow is fitted directly on top of the fireplace flange the maximum horizontal vent run before the ter- mination or a vertical rise is 36” (914 mm).
CDV SC7 & C D V7 Se ries Gas F ir e place 69D301 1 Locate vent opening on the wall.
CDV SC7 & C D V7 Se ries Gas F ir e place 69D301 1 3 Use appropriate length of pipe sections - telescopic or fixed - and install. The sections which go through the wall are packaged with the starter kit, and can be cut to suit if necessary .
CDV SC7 & C D V7 Se ries Gas F ir e place 4 69D301 1 .
CDV SC7 & C D V7 Se ries Gas F ir e place 69D301 1 5 • For the minimum height of the vent above the highest point of penetration through the roof refer to Figure 38, Page 6. Max. Height 40’ (1. m) Min. Height 8’ (.4 m) Max. 10’ (3 m) Support Straps Every 3’ (.
CDV SC7 & C D V7 Se ries Gas F ir e place 6 69D301 1 FP1184 T ypical roof/ceiling suppor t apps.
CDV SC7 & C D V7 Se ries Gas F ir e place 69D301 1 7 Use proper gas type for the fireplace you are installing. If you have conflicting gas type, do not install fireplace.
CDV SC7 & C D V7 Se ries Gas F ir e place 8 69D301 1 A listed manual shutoff valve must be installed upstream of the appliance. Union tee and plugged 1/8" NPT pressure tapping point should be installed upstream of the appliance.
CDV SC7 & C D V7 Se ries Gas F ir e place 69D301 1 9 1. Check gas type. The gas supply must be the same as stated on the appliance’s rating decal.
CDV SC7 & C D V7 Se ries Gas F ir e place 30 69D301 1 ON OFF OPTIONAL REMOTE W ALL SWITCH ON OFF OPTIONAL REMOTE CONTROL RECEIVER PILOT HI LO ON OFF TH TP TH/TP ON OFF RS FP1980 Dv wiring diagram A remote wall switch and up to fifteen (15) feet of 18 Ga.
CDV SC7 & C D V7 Se ries Gas F ir e place 69D301 1 31 .
CDV SC7 & C D V7 Se ries Gas F ir e place 3 69D301 1 This appliance is equipped with a pilot which must be lit with built-in piezo ignitor while following these instructions exactly .
CDV SC7 & C D V7 Se ries Gas F ir e place 69D301 1 33 PILOT O F F P I L O T O N FP1935 control kn.
CDV SC7 & C D V7 Se ries Gas F ir e place 34 69D301 1 PILOT O F F P I L O T O N O F F P I L O T O.
CDV SC7 & C D V7 Se ries Gas F ir e place 69D301 1 35 This appliance is equipped with an ignition device (Piezo) which automatically lights the pilot.
CDV SC7 & C D V7 Se ries Gas F ir e place 36 69D301 1 1.
CDV SC7 & C D V7 Se ries Gas F ir e place 69D301 1 37 1. This should be done before framing the fireplace. Wire the receptacle into an electrical circuit. Wire with minimum 60° C wire in accordance with prevailing codes.
CDV SC7 & C D V7 Se ries Gas F ir e place 38 69D301 1 T o Junction Box in Fireplace Optional AC Module { White Black Optional Light White Black { Optional Blower White Black { Optional Aux. Green Plug in Connector Connector Pin T o Control Board Input 300 W att Max.
CDV SC7 & C D V7 Se ries Gas F ir e place 69D301 1 39 To Junction Box In Fireplace WHITE BLACK WHITE BLACK BLACK WHITE GREEN Connector Pin To Contro l Box { { Optional Light Optional AUX Blower (3.
CDV SC7 & C D V7 Se ries Gas F ir e place 40 69D301 1 .
CDV SC7 & C D V7 Se ries Gas F ir e place 69D301 1 41 This appliance is equipped with an ignition device which automatically lights the pilot.
CDV SC7 & C D V7 Se ries Gas F ir e place 4 69D301 1 1.
CDV SC7 & C D V7 Se ries Gas F ir e place 69D301 1 43 • Easy Access Function Operation and System Configuration • Operation.
CDV SC7 & C D V7 Se ries Gas F ir e place 44 69D301 1 All System configuration/setup is done on the Command Center . When using On/Off wall switch, the switch must be in the ON position to perform all configuration set ups at the command center .
CDV SC7 & C D V7 Se ries Gas F ir e place 69D301 1 45 1.
CDV SC7 & C D V7 Se ries Gas F ir e place 46 69D301 1 1. Remove upper and lower louvers.
CDV SC7 & C D V7 Se ries Gas F ir e place 69D301 1 47 L G637 CDV logs Figure 63 1. Place rear log (#1) on grate assembly . Log should rest firmly on the two log mounting pins shown.
CDV SC7 & C D V7 Se ries Gas F ir e place 48 69D301 1 Keep the control compartment, logs, and burner areas surrounding the logs clean by vacuuming or brushing at least twice a year .
CDV SC7 & C D V7 Se ries Gas F ir e place 69D301 1 49 The fireplace and venting system should be inspected before initial use and at least annually by a quali- fied field service person.
CDV SC7 & C D V7 Se ries Gas F ir e place 50 69D301 1 1.
CDV SC7 & C D V7 Se ries Gas F ir e place 69D301 1 51 4. Frequent pilot outage problem.
CDV SC7 & C D V7 Se ries Gas F ir e place 5 69D301 1 1.
CDV SC7 & C D V7 Se ries Gas F ir e place 69D301 1 53 OPERA TION Install batteries and/or plug in the AC board Flip the master switch (rocker switc.
CDV SC7 & C D V7 Se ries Gas F ir e place 54 69D301 1 1 4 2 3 6 6 5 (CDVR Series) 5 (.
CDV SC7 & C D V7 Se ries Gas F ir e place 69D301 1 55 .
CDV SC7 & C D V7 Se ries Gas F ir e place 56 69D301 1 .
CDV SC7 & C D V7 Se ries Gas F ir e place 69D301 1 57 .
CDV SC7 & C D V7 Se ries Gas F ir e place 58 69D301 1 .
CDV SC7 & C D V7 Se ries Gas F ir e place 69D301 1 59 1 2 3 4 20 5 6 7 8 9 13,14,15,16,17 693011 cdvrt7 SC par ts 12 .
CDV SC7 & C D V7 Se ries Gas F ir e place 60 69D301 1 .
CDV SC7 & C D V7 Se ries Gas F ir e place 69D301 1 61 1 3 2 693011 cdv log par ts .
CDV SC7 & C D V7 Se ries Gas F ir e place 6 69D301 1 V ertical V.
CDV SC7 & C D V7 Se ries Gas F ir e place 69D301 1 63 Horizontal V .
CDV SC7 & C D V7 Se ries Gas F ir e place 64 69D301 1.
CDV SC7 & C D V7 Se ries Gas F ir e place 69D301 1 65.
CDV SC7 & C D V7 Se ries Gas F ir e place 66 69D301 1 This product must be installed by a licensed plumber or gas fitter when installed within the Commonwealth of Massachusetts.
CDV SC7 & C D V7 Se ries Gas F ir e place 69D301 1 67 .
149 Cleveland Drive • Paris, Kentucky 40361 www .mhsc.com Based on CSA P .4.1-09 Based on CSA P .4.1-09 Recher chez dans la br ochure les caractéristique de rendement énergétique de f oy er au gaz Énerguide Selon CSA P .
Un point important après l'achat de l'appareil (ou même avant l'achat) est de lire le manuel d'utilisation. Nous devons le faire pour quelques raisons simples:
Si vous n'avez pas encore acheté Monessen Hearth CDVR33N/PV7;N/PE7;N/PSC7 c'est un bon moment pour vous familiariser avec les données de base sur le produit. Consulter d'abord les pages initiales du manuel d'utilisation, que vous trouverez ci-dessus. Vous devriez y trouver les données techniques les plus importants du Monessen Hearth CDVR33N/PV7;N/PE7;N/PSC7 - de cette manière, vous pouvez vérifier si l'équipement répond à vos besoins. Explorant les pages suivantes du manuel d'utilisation Monessen Hearth CDVR33N/PV7;N/PE7;N/PSC7, vous apprendrez toutes les caractéristiques du produit et des informations sur son fonctionnement. Les informations sur le Monessen Hearth CDVR33N/PV7;N/PE7;N/PSC7 va certainement vous aider à prendre une décision concernant l'achat.
Dans une situation où vous avez déjà le Monessen Hearth CDVR33N/PV7;N/PE7;N/PSC7, mais vous avez pas encore lu le manuel d'utilisation, vous devez le faire pour les raisons décrites ci-dessus,. Vous saurez alors si vous avez correctement utilisé les fonctions disponibles, et si vous avez commis des erreurs qui peuvent réduire la durée de vie du Monessen Hearth CDVR33N/PV7;N/PE7;N/PSC7.
Cependant, l'un des rôles les plus importants pour l'utilisateur joués par les manuels d'utilisateur est d'aider à résoudre les problèmes concernant le Monessen Hearth CDVR33N/PV7;N/PE7;N/PSC7. Presque toujours, vous y trouverez Troubleshooting, soit les pannes et les défaillances les plus fréquentes de l'apparei Monessen Hearth CDVR33N/PV7;N/PE7;N/PSC7 ainsi que les instructions sur la façon de les résoudre. Même si vous ne parvenez pas à résoudre le problème, le manuel d‘utilisation va vous montrer le chemin d'une nouvelle procédure – le contact avec le centre de service à la clientèle ou le service le plus proche.
