Manuel d'utilisation / d'entretien du produit KLN 90B du fabricant Honeywell
Aller à la page of 152
INST ALLA TION MANU AL KLN 90B GPS RNA V MANU AL NUMBER 006-10521-0005 REVISION 5 Apr il, 2003.
W ARNING Prior to Expor t of this Document, revie w f or e xpor t license requirement is needed. COPYRIGHT NO TICE ©1997,2003 Hone ywell International Inc. Reproduction of this pub lication or any por tion thereof b y any means without t he e xpress written perm ission of Honeyw ell is prohibited.
BENDIX/KING KLN 90B Re v 5, April/2003 10521I05.TDC P age i SECTION I GENERAL INFORMATION Paragraph Page 1.1 INTRODUCTIO N ........ . .......... . ......... . .......... . ......... . .......... . .......... . ......... . ....... . 1-1 1.2 EQUIPMENT DESCRIPTION .
BENDIX/KING KLN 90B P age ii 10521I05.TDC Re v 5, April/2003 SECTION II INSTALLATION ParagraphPage 2.1 G ENERAL INFORMATION ..... . ......... . .......... . ......... . .......... . .......... . ......... . ..... 2-1 2.2 UNPACKING AND INSPECTING EQUIPMENT .
BENDIX/KING KLN 90B Re v 5, April/2003 10521I05.TDC P age iii SECTION III OPERATION Paragraph Page 3.1 G ENERAL INFORMATION .... . ......... . .......... . ......... . .......... . .......... . ......... . ..... 3-1 LIST OF ILLUSTRATIONS Figure Page 2-1 KLN 90B CONNECTOR P I N F U NCTIONS .
BENDIX/KING KLN 90B P age iv 10521I05.TDC Re v 5, April/2003 APPENDIX A RS-232 FORMAT DEFINITIONS APPENDIX B KLN 90B SUPPLEMENTAL PROCED U RES MA N UAL KLN 90B AIRPLANE FLIGHT MA N UAL SUPPLEME N T KL.
BENDIX/KING KLN 90B Re v 5, April/2003 10521I05.TDC P age 1-1 SECTION I GENERAL INFORMATION 1.1 INTRODUCTION This manual contains information relative to the physical, mechanical, and electrical character- istics of the BENDIX/KING KLN 90B Global Posi tioning System (GPS) Receiver.
BENDIX/KING KLN 90B P age 1-2 10521I0 5.TDC Rev 5, April/2003 The following labels are received on the EFIS 429 receiver inputs (Pins 4 a nd 5 of P901): TABLE 3-1 EFIS 429 Receiver Inputs The followin.
BENDIX/KING KLN 90B Re v 5, April/2003 10521I05.TDC P age 1-3 The following labels are transmi tted by the KLN 90B on the ARINC 429 transmitter output (Pins 23 and 24 of P901): TABLE 3-4 Arinc 429 Gam.
BENDIX/KING KLN 90B P age 1-4 10521I0 5.TDC Rev 5, April/2003 For RS 2 32 I/O formats, refer to A p pendix A . 310 PRESENT POSITION LATITUDE 311 PRESENT POSITION LONGITUDE 312 GROUND SPEED 313 TRACK A.
BENDIX/KING KLN 90B Re v 5, April/2003 10521I05.TDC P age 1-5 1.3.3 UNIT TECHNICAL CHARACTERISTICS Table 3-6 KLN 90b TSO Compliance SEE TSO APPENDIX Physical Dimensions: Width: 6.312 in. (16.03 cm.) Height: 2.00 in. (5.08 cm.) Length: 12.55 in. (31.87 cm.
BENDIX/KING KLN 90B P age 1-6 10521I0 5.TDC Rev 5, April/2003 Table 3-7 KLN 90B Si gnal Inputs Table 3-8 KLN 90B Gray Co de Inputs GPS DISPLAYED: OPEN = GPS displayed (when an indicator resolver is co.
BENDIX/KING KLN 90B Re v 5, April/2003 10521I05.TDC P age 1-7 Table 3-9 KLN 90B Signal Outputs Table 3-10 KLN 90B NAV Flag Output OBI SYNC, CLOCK, & DA- TA: Honeywell Serial Data containi ng beari.
BENDIX/KING KLN 90B P age 1-8 10521I0 5.TDC Rev 5, April/2003 Table 3-11 KLN 90B To/From Flag Output KA 91 ANTENNA Table 3-12 KA 91 To Indication: +40 to +160 mV on Pin 21 with respect to Pin 20 From .
BENDIX/KING KLN 90B Re v 5, April/2003 10521I05.TDC P age 1-9 Table 3-13 KA 92 KA 92 ANTENNA Table 3-14 KA 198 Comm Filter P/N 071-01565-0000 NOTE The conditions and tests pe rformed on this article are minimum performance standards.
BENDIX/KING KLN 90B P age 1-10 10521I05.TDC Re v 5, April/2003 1.4 UNITS AND A CCESSORIES SUPPLIED 1.4.1 KLN 90B GPS RECEIVER The KLN 90B is available in the following ve rsions. New manufactured KLN 90 B units are P/N 066-04031-1X21/1X22/1X24 and KLN 90/A u nits that have been converted to KLN 90B are P/ N 066-04031-2X21/2X22/2X24.
BENDIX/KING KLN 90B Re v 5, April/2003 10521I05.TDC Page 1- 11 1.4.2 GP S ANTENNA The KA 91 antenna is availab le by ordering P/N 071-01545-0200. The KA 92 antenna is available by ordering P/N 071-01553-0200. 1.4.3 KLN 90/90B INSTALLATION KIT S The KLN 90/90B Installation Kit (P/N 050-03096-0000 ) is available with cr imp connectors only.
BENDIX/KING KLN 90B P age 1-12 10521I05.TDC Re v 5, April/2003 1.4.4 KA 91/92 INSTALLATION KIT The KA 91 Installation Kit (P/N 050-03195-0000) , including its contents, is shown below. Table 3-17 KA 91 Installation Kits Earlier installation kits included a straight TNC coa x connector, P/N 030-00134-0000.
BENDIX/KING KLN 90B Re v 5, April/2003 10521I05.TDC P age 1-13 1.5 ACCESSORIES REQUIRED, BUT NOT SUPPLIED A. Forced Air Cooling A KA 33 Cooling Kit or equivalent is required fo r the KLN 90B installation. 1. KA 33 Blower for 14 VDC installations is available under P/N 071-4037-00.
BENDIX/KING KLN 90B P age 1-14 10521I05.TDC Re v 5, April/2003 Functions of the -0101 include converting 3-wi re heading sources to ARINC 429, convert- ing the resolver output of a no n-driven HSI to .
BENDIX/KING KLN 90B Re v 5, April/2003 10521I05.TDC Page 1- 15 NOTE The part numbers shown in paren thesis are annun- ciators previously called out and may be used until supply is depleted. Replacement bulbs for 031-00785-xxxx 5V 037-00009-0007 14V 037-00009-0008 28V 037-00009-0006 KLN 90B Enroute/Terminal Set for CDI or Elect.
BENDIX/KING KLN 90B P age 1-16 10521I05.TDC Re v 5, April/2003 KLN 90B Ann. Set (28 V. Ltg.) NAV/GPS Sw. Ann. 031-00785-0711 or (031-00763- 0 711) WPT/MSG Ann. 031-00785-0505 or (031-00763- 0505/-0718) GPS CRS OB S/LEG Sw. Ann. 031-00785-0778 or (031-00785-0 763) GPS APR AR M/ACT Sw.
BENDIX/KING KLN 90B Re v 5, April/2003 10521I05.TDC Page 1- 17 EFIS or KLN90A to 90B Upgrade Ann . Set (28 V. ltg.) GPS CRS OB S/LEG Sw. Ann. 031-00785-0778 or (031-00785-0 763) GPS APR AR M/ACT Sw. Ann. 031-00785-0766 EFIS or KLN90A to 90B Upgrade Ann .
BENDIX/KING KLN 90B P age 1-18 10521I05.TDC Re v 5, April/2003 FOUR FIELD ANNUNCIATORS (WPT/MSG/---/---) LIGHTING Honeywell P/N 28 V 031-00763-0718 14 V 031-00763-0719 5 V 031-00763 -0720 NOTE: (WPT) AND (MSG) will be in ambe r color and the dashes in green.
BENDIX/KING KLN 90B Re v 5, April/2003 10521I05.TDC P age 1-19 GPS APR, ARM/ACTV Switch/Annunciator The KLN 90B requires a switch/annunciator for arming , disarming, or deactivating the approach mode.
BENDIX/KING KLN 90B P age 1-20 10521I05.TDC Re v 5, April/2003 NOTE The KPI 552/553/553A’s interfaced to the KNR 665 digital Gold Crown are not compatible with the KLN 90B.
BENDIX/KING KLN 90B Re v 5, April/2003 10521I05.TDC P age 1-21 The KLN 90/90A’s upgraded to KLN 90B’s that are below S/N 154 2 still will not have isolation diodes and may need to have them added to the installation .
BENDIX/KING KLN 90B P age 1-22 10521I05.TDC Re v 5, April/2003.
BENDIX/KING KLN 90B Re v 5, April/2003 10521I05.TDC P age 2-1 SECTION II INSTALLATION 2.1 GENERAL INFORMATION This section contains general su ggestions and inform ation to consider before installation of the KLN 90B GPS RNAV. Close adherence to these su g gestions will assure optimum performance from the equipment.
BENDIX/KING KLN 90B P age 2-2 10521I0 5.TDC Rev 5, April/2003 2.3.3 ANTENNA SELECTION The KA 91 and KA 92 GPS active antennas, P/N 071-0154 5-0200 and 071-01553-0200 re spec- tively, are the designated antenn as for the KLN 90B. 2.3.4 ANTENNA INSTALLATION CONSIDERATIONS The antenna should be mounted on to p of the fuselage near the cockpit.
BENDIX/KING KLN 90B Re v 5, April/2003 10521I05.TDC P age 2-3 2.3.5 ANTENNA MECHANICAL INSTALLATION 2.3.5.1 General To maintain good performance from the antenn a system, do not wax or paint the antenna. 2.3.5.2 Installation Procedure A. Using the correct template for the antenna chosen, mark the mo unting holes on the aircraft fuselage.
BENDIX/KING KLN 90B P age 2-4 10521I0 5.TDC Rev 5, April/2003 2.3.6.2 Functional Pinout Descriptions This section gives a brief description of some of the inputs and outputs of the KLN 90B. It is provided so the installe r can determine what specific wirin g needs to be done to the aircraft in which the unit is to be installed.
BENDIX/KING KLN 90B Re v 5, April/2003 10521I05.TDC P age 2-5 H. Pin 13; RS 232 Out The KLN 90B outputs data in RS 2 32 format on this pin. It can be used to inter- face with certain types of ELT’s, fuel sensors, and moving map displays, and fuel ma n agement sys t ems.
BENDIX/KING KLN 90B P age 2-6 10521I0 5.TDC Rev 5, April/2003 O. Pins 23 and 24; GPS 429 Transmitt er outputs Pins 23 and 24 are the GPS ARINC 429 transmitter output port of the KLN 90B. For sp e c i f ic l a bel i n form a tion tr a nsmitted o n t his b us refer to Par a graph 1.
BENDIX/KING KLN 90B Re v 5, April/2003 10521I05.TDC P age 2-7 U. Pin 34; Data Loader Out Pin 34 outputs Data Loader information in RS 232 format. It can be used to in- terface with a laptop IBM compatible PC to load the database. V. Pin 35; Data Loader In Pin 35 inputs Data Loa der information in RS 232 format.
BENDIX/KING KLN 90B P age 2-8 10521I0 5.TDC Rev 5, April/2003.
BENDIX/KING KLN 90B Re v 5, April/2003 10521I05.TDC P age 2-9 FIGURE 2-1 KLN 90B CONNECTOR PIN FUNCTIONS.
BENDIX/KING KLN 90B Re v 5, April/2003 10521I05.TDC Page 2- 11 FIGURE 2-2 KLN 90B CRIMPING AND INSER TION/EXTRACTION T OOLS.
BENDIX/KING KLN 90B P age 2-12 10521I05.TDC Re v 5, April/2003.
BENDIX/KING KLN 90B Re v 5, April/2003 10521I05.TDC P age 2-13 FIGURE 2-3 KLN 90B INST ALLA TION DRA WING (DWG . NO. 155-05818-0000 R-AB).
BENDIX/KING KLN 90B Re v 5, April/2003 10521I05.TDC Page 2- 15 FIGURE 2-4 KA 91 OUTLINE (DWG . NO. 071-01545-0200 R-4).
BENDIX/KING KLN 90B P age 2-16 10521I05.TDC Re v 5, April/2003.
BENDIX/KING KLN 90B Re v 5, April/2003 10521I05.TDC P age 2-17 FIGURE 2-5 KA 91 INST ALLA TION DRA WING (DWG . NO. 155-05999-0000 R-5).
BENDIX/KING KLN 90B Re v 5, April/2003 10521I05.TDC P age 2-19 FIGURE 2-6 KA 91 BACKPLA TE OUTLINE (DWG . NO. 047-10130-0000/0002 R-2).
BENDIX/KING KLN 90B Re v 5, April/2003 10521I05.TDC Page 2- 21 FIGURE 2-7 KA 92 OUTLINE DRA WING (DWG . NO. 071-01553-0200 R-AB).
BENDIX/KING KLN 90B P age 2-22 10521I05.TDC Re v 5, April/2003.
BENDIX/KING KLN 90B Re v 5, April/2003 10521I05.TDC P age 2-23 FIGURE 2-8 KA 92 INST ALLA TION DRA WING (DWG . NO. 155-06019-0000 R-2).
BENDIX/KING KLN 90B Re v 5, April/2003 10521I05.TDC P age 2-25 FIGURE 2-9 KA 92 BACKPLA TE OUTLINE (DWG . NO. 047-10735-0000/0002 R-1).
BENDIX/KING KLN 90B Re v 5, April/2003 10521I05.TDC Page 2- 27 FIGURE 2-10 KA 91/92 TNC ANTENNA COAX/CONNECTOR ASSEMBL Y RG142B/U OR RG400 0 TO 40 FT .
BENDIX/KING KLN 90B P age 2-28 10521I05.TDC Re v 5, April/2003.
BENDIX/KING KLN 90B Re v 5, April/2003 10521I05.TDC P age 2-29 FIGURE 2-1 1 KA 91/92 BMA ANTENNA COAX/CONNECTOR ASSEMBL Y (RG142 B/U OR RG400 0 TO 40 FT .
BENDIX/KING KLN 90B Re v 5, April/2003 10521I05.TDC Page 2- 31 FIGURE 2-12 KA 91/92 TNC ANTENNA COAX/CONNECTOR ASSEMBL Y 0 TO 80 FT . / 0 TO 100 FT . (FOR CABLE P/N’S 024-0 0071-0000, R-0 / 024-0007.
BENDIX/KING KLN 90B P age 2-32 10521I05.TDC Re v 5, April/2003.
BENDIX/KING KLN 90B Re v 5, April/2003 10521I05.TDC P age 2-33 FIGURE 2-13 KA 33 P/N 0 71-4037-00/01 FINAL ASSEMBL Y (DWG . NO. 300-03256-0000, R-AA).
BENDIX/KING KLN 90B Re v 5, April/2003 10521I05.TDC P age 2-35 FIGURE 2-14 KA 33 P/N 071-4037- 00/01 OUTLINE AND MOUNTING (DWG . NO. 155-05574-0000, R-5).
BENDIX/KING KLN 90B Re v 5, April/2003 10521I05.TDC P age 2-37 FIGURE 2-15 CUTLER-HAMMER SW ITCH/ANNUNCIA T O R MOUNTING.
BENDIX/KING KLN 90B Re v 5, April/2003 10521I05.TDC Page 2- 39 FIGURE 2-16 CUTLER-HAMME R SWITCH/ANNUNCIA T OR INTERNAL SCHEMA TIC (SHEET 1 OF 2).
BENDIX/KING KLN 90B P age 2-40 10521I05.TDC Re v 5, April/2003.
BENDIX/KING KLN 90B Re v 5, April/2003 10521I05.TDC P age 2-41 FIGURE 2-16 CUTLER-HAMME R SWITCH/ANNUNCIA T OR INTERNAL SCHEMA TIC (SHEET 2 OF 2).
BENDIX/KING KLN 90B Re v 5, April/2003 10521I05.TDC P age 2-43 FIGURE 2-17 KLN 90B INTERCONNECT DRA WING (DWG . NO. 155-06021-0000, R-AC) (SHEET 1 OF 10).
BENDIX/KING KLN 90B Re v 5, April/2003 10521I05.TDC P age 2-45 FIGURE 2-17 KLN 90B INTERCONNECT DRA WING (DWG . NO. 155-06021-0000, R-AC) (SHEET 2 OF 10).
BENDIX/KING KLN 90B Re v 5, April/2003 10521I05.TDC P age 2-47 FIGURE 2-17 KLN 90B INTERCONNECT DRA WING (DWG . NO. 155-06021-0000, R-AC) (SHEET 3 OF 10).
BENDIX/KING KLN 90B Re v 5, April/2003 10521I05.TDC P age 2-49 FIGURE 2-17 KLN 90B INTERCONNECT DRA WING (DWG . NO. 155-06021-0000, R-AC) (SHEET 4 OF 10).
BENDIX/KING KLN 90B Re v 5, April/2003 10521I05.TDC P age 2-51 FIGURE 2-17 KLN 90B INTERCONNECT DRA WING (DWG . NO. 155-06021-0000, R-AC) (SHEET 5 OF 10).
BENDIX/KING KLN 90B Re v 5, April/2003 10521I05.TDC P age 2-53 FIGURE 2-17 KLN 90B INTERCONNECT DRA WING (DWG . NO. 155-06021-0000, R-AC) (SHEET 6 OF 10).
BENDIX/KING KLN 90B Re v 5, April/2003 10521I05.TDC P age 2-55 FIGURE 2-17 KLN 90B INTERCONNECT DRA WING (DWG . NO. 155-06021-0000, R-AC) (SHEET 7 OF 10).
BENDIX/KING KLN 90B Re v 5, April/2003 10521I05.TDC P age 2-57 FIGURE 2-17 KLN 90B INTERCONNECT DRA WING (DWG . NO. 155-06021-0000, R-AC) (SHEET 8 OF 10).
BENDIX/KING KLN 90B Re v 5, April/2003 10521I05.TDC P age 2-59 FIGURE 2-17 KLN 90B INTERCONNECT DRA WING (DWG . NO. 155-06021-0000, R-AC) (SHEET 9 OF 10).
BENDIX/KING KLN 90B Re v 5, April/2003 10521I05.TDC P age 2-61 FIGURE 2-17 KLN 90B INTERCONNECT DRA WING (DWG . NO. 155-06021-0000, R-AC) (SHEET 10 OF 10).
BENDIX/KING KLN 90B Re v 5, April/2003 10521I05.TDC P age 2-63 FIGURE 2-18 KLN 90B DA T ALOADER/PC INTERF ACE DRA WING.
BENDIX/KING KLN 90B Re v 5, April/2003 10521I05.TDC P age 2-65 2.4 POST INSTALLATION CHECK OUT INFORMATION 2.4.1 KLN 90B RESOLVER CALIBRATION METHOD The KLN 90B supports both 400 Hz and 30 Hz re solvers. However, to assure maximum accuracy, the KLN 90B will need to be calibrated so that it will work with either type.
BENDIX/KING KLN 90B P age 2-66 10521I05.TDC Re v 5, April/2003 The second part of this procedure deals with a n instal lation in which some or all of the electr ical signal I/O have been utilized.
BENDIX/KING KLN 90B Re v 5, April/2003 10521I05.TDC P age 2-67 1. The 12th and 13th harmonics of the above mentioned frequencies can be radiated from the VHF COMM at a level strong enoug h to be a problem to the GPS but still be well low enough to meet TSO requirements for the VHF COMM.
BENDIX/KING KLN 90B P age 2-68 10521I05.TDC Re v 5, April/2003 OBS knob. Verify that the selected course value displayed on the Mode Page 2 tracks the new value selected . In the OBS mode with the GPS displayed on th e CDI/HSI, the resolver is disconnected from the NAV converter.
BENDIX/KING KLN 90B Re v 5, April/2003 10521I05.TDC P age 2-69 2.4.4.9 External Annunciators Recycle the power on the KLN 90B which will cause the Self Test Page to be displayed. Ve rify that all external annunciators a re energized. Cycl e the KLN 90B display past all initialization pages.
BENDIX/KING KLN 90B P age 2-70 10521I05.TDC Re v 5, April/2003 2.4.4.14 Roll Steering Interface Roll Steering is dependent on ground speed to calculate and cannot be displayed on the ground in the Nav mode. However the KLN 90B will test the roll steering while on the system test page and activate all the outputs.
BENDIX/KING KLN 90B Re v 5, April/2003 10521I05.TDC P age 3-1 SECTION III OPERATION 3.1 GENERAL INFORMATION For an explanation of the operat ing controls of the KLN 90B GPS RNAV refer to the KLN 90B pilots guide (P/N 006-08773-0000) or the aircraft’s flight manual supplement.
BENDIX/KING KLN 90B P age 3-2 10521I0 5.TDC Rev 5, April/2003.
BENDIX/KING KLN 90B Re v 5, April/2003 10521I05.TDC P age A-1 APPENDIX A RS-232 FORMAT DEFINITIONS.
BENDIX/KING KLN 90B P age A-2 1 0521I05.TDC Rev 5, April/2003 THIS PAGE RESERVED.
BENDIX/KING KLN 90B Re v 5, April/2003 10521I05.TDC P age A-3 1.0 RS-232 The RS-232 interface will have the following characteristics: Electrical per EIA RS232C 9600 baudrate, 8 bits, 1 start bit, 1 s.
BENDIX/KING KLN 90B P age A-4 1 0521I05.TDC Rev 5, April/2003 1.1.2 TEST MODE ONLY : RS-232 I < O > Fuel Sensor ELT and/or moving map and/or PC fuel data self-test data navigation data RS-232 I .
BENDIX/KING KLN 90B Re v 5, April/2003 10521I05.TDC P age A-5 1.2 RS-232 OUTPUTS 1.2.1 NAVIGATION AND SELF-TEST DATA RS-232 data will be output with the following format: <STX><id><dddd><it><id><dddd ><it>.
BENDIX/KING KLN 90B P age A-6 1 0521I05.TDC Rev 5, April/2003 l dddd dd 6 distance to destination dddddd=nm * 1 0 t abcdefghij 10 GPS discretes a=W for waypoint aler t, T for in turn, dashed other wis.
BENDIX/KING KLN 90B Re v 5, April/2003 10521I05.TDC P age A-7 Self-test Data The following ASCII format is u sed for self-test data: abcdeeeeffffgggghhhhiiiijjjj : 28 bytes where Bit Message Descripti.
BENDIX/KING KLN 90B P age A-8 1 0521I05.TDC Rev 5, April/2003 hhhh IC designator in case of RAM failure iiii IC designator in ca se of EPROM failure jjjj IC designator in case of NV RAM failure Flight.
BENDIX/KING KLN 90B Re v 5, April/2003 10521I05.TDC P age A-9 s = 0 North latitude s = 1 South latitude x = Undefined ddddddd = Latitude degrees mmmmmm = Latitude minutes hhhhhhh = Latitude hundredths.
BENDIX/KING KLN 90B P age A-10 10521I05.TDC Re v 5, April/2003 1.3 RS-232 INPUTS 1.3.1 FUEL/AIR DATA INPUT One of the following 4 ASCII formats shall be transmitted.
BENDIX/KING KLN 90B Re v 5, April/2003 10521I05.TDC P age A-11 ASCII-coded decimal fo rmat (least significan t digit is tenths), LSB first. Example: A fuel remaining value of 543.2 would be sent as "2. 3450" (32H, 2EH, 33H, 34H, 35H, 30H). 9 Total Fuel Remaining Checksum Break each decimal value into its BCD r epresen tation.
BENDIX/KING KLN 90B P age A-12 10521I05.TDC Re v 5, April/2003 Byte Data 52-54 indicated airspeed (IAS, knots) ASCII-coded decimal fo rmat (least significant di git is units), LSB first . Example: An IAS of 2 98 knots would be sent as "892" (38H, 39H, 32H).
BENDIX/KING KLN 90B Re v 5, April/2003 10521I05.TDC P age A-13 93 drift checksum sum for drift bytes, exclu ding the direction character. Example: The sum for "41L" would be "5" (35H). 94-98 rate of change of PALT (feet/minute) ASCII-coded d ecimal form at with a sign character .
BENDIX/KING KLN 90B P age A-14 10521I05.TDC Re v 5, April/2003.
BENDIX/KING KLN 90B Re v 5, April/2003 10521I05.TDC P age B-1 APPENDIX B Includes the following: KLN 90B SUPPLEMENTA L PROCEDURES MANUAL KLN 90B AIRPLANE FLIGHT MANUAL SUPPLEMENT KLN 90B SUPPLEMENTAL .
BENDIX/KING KLN 90B P age B-2 1 0521I05.TDC Rev 5, April/2003 THIS PAGE RESERVED.
BENDIX/KING KLN 90B Re v 5, April/2003 10521I05.TDC P age B-3.
BENDIX/KING KLN 90B P age B-4 1 0521I05.TDC Rev 5, April/2003.
BENDIX/KING KLN 90B Re v 5, April/2003 10521I05.TDC P age B-5.
BENDIX/KING KLN 90B P age B-6 1 0521I05.TDC Rev 5, April/2003.
BENDIX/KING KLN 90B Re v 5, April/2003 10521I05.TDC P age B-7.
BENDIX/KING KLN 90B P age B-8 1 0521I05.TDC Rev 5, April/2003.
BENDIX/KING KLN 90B Re v 5, April/2003 10521I05.TDC P age B-9.
BENDIX/KING KLN 90B P age B-10 10521I05.TDC Re v 5, April/2003.
BENDIX/KING KLN 90B Re v 5, April/2003 10521I05.TDC P age B-11.
BENDIX/KING KLN 90B P age B-12 10521I05.TDC Re v 5, April/2003.
BENDIX/KING KLN 90B Re v 5, April/2003 10521I05.TDC P age B-13.
BENDIX/KING KLN 90B P age B-14 10521I05.TDC Re v 5, April/2003.
BENDIX/KING KLN 90B Re v 5, April/2003 10521I05.TDC P age B-15.
BENDIX/KING KLN 90B P age B-16 10521I05.TDC Re v 5, April/2003.
BENDIX/KING KLN 90B Re v 5, April/2003 10521I05.TDC P age B-17.
BENDIX/KING KLN 90B P age B-18 10521I05.TDC Re v 5, April/2003.
BENDIX/KING KLN 90B Re v 5, April/2003 10521I05.TDC P age B-19.
BENDIX/KING KLN 90B P age B-20 10521I05.TDC Re v 5, April/2003.
BENDIX/KING KLN 90B Re v 5, April/2003 10521I05.TDC P age B-21.
BENDIX/KING KLN 90B P age B-22 10521I05.TDC Re v 5, April/2003.
BENDIX/KING KLN 90B Re v 5, April/2003 10521I05.TDC P age B-23.
BENDIX/KING KLN 90B P age B-24 10521I05.TDC Re v 5, April/2003.
BENDIX/KING KLN 90B Re v 5, April/2003 10521I05.TDC P age B-25.
BENDIX/KING KLN 90B P age B-26 10521I05.TDC Re v 5, April/2003.
BENDIX/KING KLN 90B Re v 5, April/2003 10521I05.TDC P age B-27.
BENDIX/KING KLN 90B P age B-28 10521I05.TDC Re v 5, April/2003.
BENDIX/KING KLN 90B Re v 5, April/2003 10521I05.TDC P age B-29.
BENDIX/KING KLN 90B P age B-30 10521I05.TDC Re v 5, April/2003.
BENDIX/KING KLN 90B Re v 5, April/2003 10521I05.TDC P age B-31.
BENDIX/KING KLN 90B P age B-32 10521I05.TDC Re v 5, April/2003.
BENDIX/KING KLN 90B Re v 5, April/2003 10521I05.TDC P age B-33.
BENDIX/KING KLN 90B P age B-34 10521I05.TDC Re v 5, April/2003.
BENDIX/KING KLN 90B Re v 5, April/2003 10521I05.TDC P age B-35.
BENDIX/KING KLN 90B P age B-36 10521I05.TDC Re v 5, April/2003.
BENDIX/KING KLN 90B Re v 5, April/2003 10521I05.TDC P age B-37.
BENDIX/KING KLN 90B P age B-38 10521I05.TDC Re v 5, April/2003.
BENDIX/KING KLN 90B Re v 5, April/2003 10521I05.TDC P age B-39.
BENDIX/KING KLN 90B P age B-40 10521I05.TDC Re v 5, April/2003.
BENDIX/KING KLN 90B Re v 5, April/2003 10521I05.TDC P age C-1 APPENDIX C GPS FAULT/ERROR CODES AND MESSAGES.
BENDIX/KING KLN 90B P age C-2 1 0521I05.TDC Rev 5, April/2003 THIS PAGE RESERVED.
BENDIX/KING KLN 90B Re v 5, April/2003 10521I05.TDC P age C-3 KLN 90B GPS FAULT/ERROR CODES, MESSAG ES(FROM INSTALLATION BULLETIN 410) The f ollowin g tables contain some helpful inf orm ation to aid in the troub leshooting of the KLN 90B GPS . When the GPS displa y or the personal co mputer monitor indicates a GPS Rec.
BENDIX/KING KLN 90B P age C-4 1 0521I05.TDC Rev 5, April/2003 GPS Rec. error Codes Definition Suggested Action RCVR Hardwa re Error: 0010 RF Failure: This means the receiver is not sensing a proper RF signal from the satellites/antenna. It could be one of the following, in th e order of prob- ability: 1.
BENDIX/KING KLN 90B Re v 5, April/2003 10521I05.TDC P age C-5 GPS Rec. error Codes Definition Suggested Action RCVR Hardwa re Error: 1000 RS-232 Channel 2 Failure: The second RS-232 UART on the receiver failed the loop-back test. This self-test can only be enabled during test mode on the receiv- er, and should no t be seen in normal oper- ation.
BENDIX/KING KLN 90B P age C-6 1 0521I05.TDC Rev 5, April/2003 GPS P age/Laptop Messa ges GPS Message Definition Suggested Action Altitude Fail Indicates a missing or erroneous altitude. ⋅ The altitude input on the gray code input from the encoder is wrong.
BENDIX/KING KLN 90B Re v 5, April/2003 10521I05.TDC P age C-7 GPS P age/Laptop Messa ges GPS Message Definition Suggested Action RAIM not avail- able Cross check posi- tion This means there are not enough satellites available to compute in- tegrity (RAIM).
BENDIX/KING KLN 90B P age C-8 1 0521I05.TDC Rev 5, April/2003 GPS P age/Laptop Messa ges GPS Message Definition Suggested Action No RS-232 Data There is no RS-232 data at the RS-232 input port. The Air Data/Fuel Flow source is not providin g RS 232 data to the GPS.
BENDIX/KING KLN 90B Re v 5, April/2003 10521I05.TDC P age C-9 Data Loader Err or Messages Data Loader Er- ror Messages Definition Suggested Action Loader Not Ready This indicates that the computer and the GPS are not making a con- nection with each other.
BENDIX/KING KLN 90B P age C-10 10521I05.TDC Re v 5, April/2003.
BENDIX/KING KLN 90B Re v 5, April/2003 10521I05.TDC P age TSO-1 TSO APPENDIX RTCA DO-160C ENVIRONMENTAL QUALIFICATION FORMS.
BENDIX/KING KLN 90B P age TSO-2 1 0521I05.TDC Rev 5, April/2003 THIS PAGE RESERVED.
BENDIX/KING KLN 90B Re v 5, April/2003 10521I05.TDC P age TSO-3.
BENDIX/KING KLN 90B P age TSO-4 1 0521I05.TDC Rev 5, April/2003.
BENDIX/KING KLN 90B Re v 5, April/2003 10521I05.TDC P age TSO-5.
BENDIX/KING KLN 90B P age TSO-6 1 0521I05.TDC Rev 5, April/2003.
BENDIX/KING KLN 90B Re v 5, April/2003 10521I05.TDC P age TSO-7.
BENDIX/KING KLN 90B P age TSO-8 1 0521I05.TDC Rev 5, April/2003.
BENDIX/KING KLN 90B Re v 5, April/2003 10521I05.TDC P age TSO-9.
BENDIX/KING KLN 90B P age TSO-10 10521I05.TDC Rev 5, April/2003.
Un point important après l'achat de l'appareil (ou même avant l'achat) est de lire le manuel d'utilisation. Nous devons le faire pour quelques raisons simples:
Si vous n'avez pas encore acheté Honeywell KLN 90B c'est un bon moment pour vous familiariser avec les données de base sur le produit. Consulter d'abord les pages initiales du manuel d'utilisation, que vous trouverez ci-dessus. Vous devriez y trouver les données techniques les plus importants du Honeywell KLN 90B - de cette manière, vous pouvez vérifier si l'équipement répond à vos besoins. Explorant les pages suivantes du manuel d'utilisation Honeywell KLN 90B, vous apprendrez toutes les caractéristiques du produit et des informations sur son fonctionnement. Les informations sur le Honeywell KLN 90B va certainement vous aider à prendre une décision concernant l'achat.
Dans une situation où vous avez déjà le Honeywell KLN 90B, mais vous avez pas encore lu le manuel d'utilisation, vous devez le faire pour les raisons décrites ci-dessus,. Vous saurez alors si vous avez correctement utilisé les fonctions disponibles, et si vous avez commis des erreurs qui peuvent réduire la durée de vie du Honeywell KLN 90B.
Cependant, l'un des rôles les plus importants pour l'utilisateur joués par les manuels d'utilisateur est d'aider à résoudre les problèmes concernant le Honeywell KLN 90B. Presque toujours, vous y trouverez Troubleshooting, soit les pannes et les défaillances les plus fréquentes de l'apparei Honeywell KLN 90B ainsi que les instructions sur la façon de les résoudre. Même si vous ne parvenez pas à résoudre le problème, le manuel d‘utilisation va vous montrer le chemin d'une nouvelle procédure – le contact avec le centre de service à la clientèle ou le service le plus proche.
