Manuel d'utilisation / d'entretien du produit 463270613 du fabricant Char-Broil
Aller à la page of 28
Assembly instructions © 2013 PR ODUCT GUIDE MODEL 463270613 © 2013 Char-Broil, LLC Columbus, GA 31902 Printed in China Serial Number Date Purchased IMPORT ANT : Fill out the product record information below . See rating label on grill for serial number .
T ABLE OF CONTENTS 1. Do not store or use gasoline or other flammable liquids or vapors in the vicinity of this or any other appliance. 2. An LP cylinder not connected for use shall not be stored in the vicinity of this or any other appliance. WARNING For residential use only .
WARNING Installation Safety Precautions • Use grill, as purchased, only with LP (propane) gas and the regulator/valve assembly supplied. If your grill is Dual Fuel ready , a conversion kit must be purchased for use with natural gas.
• NEVER store a spare LP cylinder under or near the appliance or in an enclosed area. • Never fill a cylinder beyond 80% full. • An over filled or improperly stored cylinder is a hazard due to possible gas release from the safety relief valve. This could cause an intense fire with risk of property damage, serious injury or death.
WARNING If “growing” bubbles appear do not use or move the LP cylinder . Contact an LP gas supplier or your fire department! Connecting Regulator to the LP Cylinder 1. LP cylinder must be properly secured onto grill. (Refer to assembly section.) 2.
6. T urn the coupling nut clockwise and tighten to a full stop. The regulator will seal on the back-check feature in the LP cylinder valve, resulting in some resistance. An additional one-half to three-quarters turn is required to complete the connection.
7 ▲ ▲ ▲ ▲ ▲ ▲ ▲ ▲ ▲ ▲ ▲ ▲ Safety Tips Before opening LP cylinder valve, check the coupling nut for tightness. When grill is not in use, turn off all control knobs and LP cylinder valve. Never move grill while in operation or still hot.
8 Burner Flame Check • Remove cooking grates and flame tamers. Light burners, rotate knobs from HIGH to LOW . Y ou should see a smaller flame in LOW position than seen on HIGH . Perform burner flame check on sideburner , also. Always check flame prior to each use.
9 Cleaning the Burner Assembly Follow these instructions to clean and/or replace parts of burner assembly or if you have trouble igniting grill. 1. T urn gas OFF at control knobs and LP cylinder . 2. Remove cooking grates and flame tamers. 3. Remove carryover tubes and burners.
This warranty only applies to units purchased from an authorized retailer . Manufacturer warrants to the original consumer-pur chaser only that this product shall be free from defects in workmanship and materials after correct assembly and under normal and reasonable home use for the periods indicated below beginning on the date of purchase*.
P ARTS LIST NOTE: Some grill parts shown in the assembly steps may differ slightly in appearance from those on your particular grill model. However , the method of assembly remains the same.
P ARTS DIA GRAM MM A N E I C G K B F J D H L L M O P Q R S T U V W X Y Z AA BB CC DD EE FF GG HH II JJ KK KK LL LL NN 1 2.
1 2 Bottom shelf Non-lock caster Locking caster Rear Front Left side panel Magnet (with a hole) Right side panel Front Caster pin A A S S E M B L Y P l a c e b o t t o m s h e l f u p s i d e d o w n . I n s e r t C a s t e r P i n i n t o t h e c a s t e r m o u n t i n g p l a t e t o l o c k i t i n p l a c e , s h o w n A .
3 4 U p p e r b a c k p a n e l Left side panel Grill head Right side panel Regulator hose T h i s s t e p r e q u i r e s t w o p e o p l e t o l i f t a n d p o s i t i o n g r i l l h e a d o n t o c a r t .
15 5 6 Knob T emperature gauge T emperature gauge stem Control panel A C B Back of the panel Right side fascia Right side shelf #10-24x3/8" screw A t t a c h r i g h t s i d e f a s c i a t o r i g h t s i d e s h e l f u s i n g t w o # 1 0 - 2 4 x 3 / 8 " s c r e w s .
7 A B C Foldable side shelf Foldable side shelf Foldable side shelf S h o u l d e r s c r e w 1 / 4 " n u t Right side shelf Right side shelf T rack Bracket D A t t a c h f o l d a b l e s i d e .
F a s c i a , r i g h t s i d e s h e l f B a c k o f m a i n c o n t r o l p a n e l # 8 x 3 / 8 " s e l f - t a p p i n g 1 / 4 " n u t 1 / 4 " n u t s c r e w I g n i t e r s w i t c.
10 I n s e r t l e f t a n d r i g h t g r e a s e t r a y r a i l s i n t o s l o t s A t t a c h r i g h t a n d l e f t r a i l s u n d e r f r o n t b r a c e w i t h t w o # 8 x 3 / 8 " s e l f - t a p p i n g s c r e w s , s h o w n B . b e n e a t h g r e a s e t r a y o p e n i n g i n u p p e r b a c k p a n e l , s h o w n A .
11 12 T op of Front brace door PRESS Door I n s e r t h i n g e p i n o n b o t t o m o f d o o r i n t o h o l e i n b o t t o m s h e l f . P r e s s u p p e r h i n g e p i n i n f r o n t b r a c e , a l i g n h i n g e h o l e o n t o p o f d o o r a n d r e l e a s e h i n g e p i n i n t o d o o r.
Slide into slots Back of firebox Front of firebox Flame tamers Pin 14 13 I n s t a l l f l a m e t a m e r s b y s l i d i n g o n e e n d o f e a c h f l a m e t a m e r i n t o s l o t s a t f r o n t o f f i r e b o x a n d r e s t i n g o p p o s i t e e n d o n p i n s i n b a c k o f f i r e b o x .
CA UTION Grease tray F a i l u r e t o i n s t a l l g r e a s e t r a y w i l l c a u s e h o t g r e a s e t o d r i p f r o m b o t t o m o f g r i l l w i t h r i s k o f f i r e o r p r o p e r t y d a m a g e .
? Regulator L P C Y L I N D E R I S S O L D S E PA R AT E LY . F i l l a n d l e a k c h e c k t h e c y l i n d e r b e f o r e a t t a c h i n g t o g r i l l a n d r e g u l a t o r ( s e e U s e &.
D ANGER: If a gas leak cannot be stopped, or a fire occurs due to gas leakage, call the fire department. Emergencies Problem Gas leaking from cracked/cut/burned hose. Gas leaking from LP cylinder . Gas leaking from LP cylinder valve. Gas leaking between LP cylinder and regulator connection.
T roubleshooting ( continued ) Problem Burner(s) will not light using ignitor . (See Electronic Ignition T roubleshooting also) Burner(s) will not match light. Sudden drop in gas flow or low flame. Flames blow out. Flare-up. Persistent grease fire. Flashback.
T roubleshooting - Electronic Ignition Problem (Ignition) SECTION I No sparks appear at any electrodes when Electronic Ignition Button is pressed; no noise can be heard from spark module. SECTION II SECTION III Sparks are present but not at all electrodes and/or not at full strength Possible Cause • Battery not installed properly .
NOTES 26.
*❶ First Name | Nombre | Prénom Initial | Inicial | Initiale Last Name | Apellido | Nom de F amillie Address (number & street) | Dirección (número y calle) | Adress e (numéro et rue) Apt Number | Nº de apart | Nº d’appt.
THANK Y OU FOR Y OUR RECENT PURCHASE FROM REGISTER YOUR PRODUCT T O RECEIVE A SPECIAL OFFER CHARBROIL.C OM/REGISTER CHECK OUT THESE GREA T FEA TURES ON OUR WEBSITE • Valuable product inf ormation .
Un point important après l'achat de l'appareil (ou même avant l'achat) est de lire le manuel d'utilisation. Nous devons le faire pour quelques raisons simples:
Si vous n'avez pas encore acheté Char-Broil 463270613 c'est un bon moment pour vous familiariser avec les données de base sur le produit. Consulter d'abord les pages initiales du manuel d'utilisation, que vous trouverez ci-dessus. Vous devriez y trouver les données techniques les plus importants du Char-Broil 463270613 - de cette manière, vous pouvez vérifier si l'équipement répond à vos besoins. Explorant les pages suivantes du manuel d'utilisation Char-Broil 463270613, vous apprendrez toutes les caractéristiques du produit et des informations sur son fonctionnement. Les informations sur le Char-Broil 463270613 va certainement vous aider à prendre une décision concernant l'achat.
Dans une situation où vous avez déjà le Char-Broil 463270613, mais vous avez pas encore lu le manuel d'utilisation, vous devez le faire pour les raisons décrites ci-dessus,. Vous saurez alors si vous avez correctement utilisé les fonctions disponibles, et si vous avez commis des erreurs qui peuvent réduire la durée de vie du Char-Broil 463270613.
Cependant, l'un des rôles les plus importants pour l'utilisateur joués par les manuels d'utilisateur est d'aider à résoudre les problèmes concernant le Char-Broil 463270613. Presque toujours, vous y trouverez Troubleshooting, soit les pannes et les défaillances les plus fréquentes de l'apparei Char-Broil 463270613 ainsi que les instructions sur la façon de les résoudre. Même si vous ne parvenez pas à résoudre le problème, le manuel d‘utilisation va vous montrer le chemin d'une nouvelle procédure – le contact avec le centre de service à la clientèle ou le service le plus proche.
