Manuel d'utilisation / d'entretien du produit 915165 du fabricant Ariens
Aller à la page of 36
Zoom XL ® Owne r /Op e r at or Ma nu al Manuel Du Propriétaire/Utilisateur Models 915163 – Z oom XL 42 915165 – Z oom XL 48 915167 – Z oom XL 54 ENGLISH 04043500 10/10 Printed in USA ENGLISH F.
GB - 2 SAFET Y . . . . . . . . . . . . . . . . . . . . . . . . . . 4 ASSEMBL Y . . . . . . . . . . . . . . . . . . . . . . 1 0 CONTROLS AND FEA TURES . . . . . . . 12 OPERA TION . . . . . . . . . . . . . . . . . . . . . 13 MAINTENANCE SCHEDULE . . . .
GB - 3 • Record Unit Model and Serial numbers here. • Record Engine Model and Serial numbers here. PRODUCT REGISTRA TION The Ariens d ealer must register the product at the time of purchas e. Registering the product will help the company process warranty claims or contact you with the latest service information.
GB - 4 SAFETY ALERTS The safety alert symbol is used in decals and with this manual. Understand the safety message. It contains important information about personal safety . NOT A TIONS NOTE: General referenc e information for proper operation and maintenance pract ices.
GB - 5 1. Caution! 2. Da nger ! 3. Da nger ! 4. W arning! 077541 Read the operator’s manual. Keep children and others away from unit while operating. Never direct discharge toward other people. Thrown objects can cause injury. Look down and behind before and while backing.
GB - 6 5. Danger! T o A void Serious Inju ry or Death 6. Ho t Surfaces! 7. Caution ! 8. Dange r! Read the operator ’ s manual. Keep children and others away from unit while operating. Never direct dischar ge toward other people. Thrown objects can cause injury .
GB - 7 EMISSION CONTROL SYS TEM This equipment and/or its engine may include exhaust and evaporat ive emissions control system components required to meet U.S. Environmental Protection Agenc y (EP A) and/or California Air Resources Board (CARB) regulations.
GB - 8 DO NOT operate unit if safety int erlock system is damaged or disabled. Check safety interlock before each use. AL WA YS r emove key to prevent unauthorized use. DO NOT op erate at too fast a rate. Slow down before turning. S top engine before removing grass catcher o r unclogging chute.
GB - 9 Replace fuel cap securely and clean up spilled fuel. NEVER fill containers inside a vehicle or on a truck or trailer bed with a plastic liner . Always place containers on the gr ound away from your vehicle before filling. When practical, remov e gas-powered equipment from the t ruck or trailer and refuel it on the ground.
GB - 10 T ools Req uired • Adjustable wrench • 9/16" wrench • Petroleum jelly or dielectric grease. Unp ack Unit Remove unit and all other components from the shipping contai ner . Engage transmission bypass lever (s ee MO VING UNIT MANUALL Y on page 16).
GB - 11 Check Engine Oil Leve l Refer to Engine Manual. Level M ower Deck See LEVEL LING AND AD JUSTI N G PITCH OF MOWER DECK on page 20. Fill Fuel T ank Fill fuel tank. DO NOT OVERFILL! See FILLING FUEL T ANK on page 15. Adjust Seat See Adjusting Seat on page 15.
GB - 12 1. I gnition Switch 2. P TO Switch 3. T hrot tle Lever 4. Seat 5. Steering Levers 6. P arking Brake 7. F uel T ank 8. Mower Lift Pedal 9. Mo wer Deck 10.
GB - 13 CONTROLS AND FEA TURES See figure 5 for all controls and features locations. Safety Interlock Syste m Perform the f ollowing tests to ensure the safety interlock system is working properly . If the unit does not perform as stat ed contact your Ariens dealer for repairs.
GB - 14 Timer (TMR1): me asures the time spent on individual jobs. Press and hold the toggle button to reset the timer to zero. TMR1 will then start measuring engine run time until it is reset to zero again.
GB - 15 Adjusting Sea t Lift adjustment lever and slide seat forward or backward to the desired position. FILLING FUEL T ANK T o add f uel to the fuel tank: 1. C lean fuel caps and surrounding area to prevent dust, dirt , and debris from entering fuel tanks.
GB - 16 MOVING UNIT MANUALL Y Disengage (2) transmiss ion bypass levers to drive unit and engage (1) transmission bypass levers to push unit manually (figure 8). ST ARTING AND SHUTTING OFF ENGINE S tarting the Engine NOTE: Disengage the PTO, engage the parking brake, and place the steering l evers in neutral prior to s tarting the engine.
GB - 17 IMPORT ANT : Proper maintenance can prolong the life of unit. The following chart shows the re commended serv ice schedule. Refer to the maintena nce instructions in the Engine Manual for additional information.
GB - 18 TIPPING SEA T FORW ARD Put steering levers up and tip s eat forward. Each Use Follow Engine Manual Mainten- ance Schedule Perform scheduled engine maintenance. Refer to E ngine Manual for de tailed instructions. NOTE: T o drain the oil, use the oil drain hose (1) su pplied with unit, not the drain plug that is shown in the Engine Manual.
GB - 19 OPENING AND CLOSING HOOD T o open, pull up on the back o f the hood until hood hits t he hood stop and push down on back of hood to close (figure 10). OPENING DECK ACC ESS PLA TE 1. I nstall adjustment pin in the fi rst adjustment hole (figure 11).
GB - 20 LEVELLING AND ADJUSTING PITCH OF MOWER DE CK NOTE: Adjust on a level surface, with the tires inflated to the correct air pressure (see SPECIFICA TIONS on page 30). There are three meas urements required to level and adjust the pitch of the mower deck.
GB - 21 Adjusting The Mower Deck T o Adjust Mower Blade Height And Pitch (Figure 17): NOTE: Adjusting the mower deck will adjust the height and pi tch of the mower blades. 1. A djust the trunnions first and re-take the three measurements required to level and adjust the pitch of the m ower deck.
GB - 22 SERVICING BA T TERY NOTE: Unit comes equipped with a maintenance-free battery that requires no regular maintenance except cleaning the terminals and periodic charging. Battery Remov al and Inst allati on Remove (Fi gure 18) 1. Tip seat forwar d (see TIPPIN G SEA T FORW ARD on page 18).
GB - 23 Charging the Battery (Figure 19) Follow First Aid directions for contact with battery fluid. • External Contact: Flush with water . • Eyes: Flush with wa ter for at least 15 minutes and get m edical attention immediately! • Internal Contact: Drink large quantities of water .
GB - 24 3. Adju st Steer ing Lever F orward or Backwar d 1. Lo osen, do not remove, the bolts securing the handlebar to the upper control arm. 2. S lide steering lever forw ard or backward to desired position and tighten bolt s. NOTE: Tigt hen upper bolt first.
GB - 25 4. R emove PTO belt from left mower deck pulley . 5. S lowly release idler arm until tension is removed f rom idler spring. 6. R emove PTO belt from mower deck and electric clutch. Inst all (Fi gure 23) NOTE: Do not install PTO belt on left mower deck pulley in step 1.
GB - 26 Change Hydra ulic Fluid and Filter (Figure 26) NOTE: Change hydraulic fluid and filter after the first 75 hours of operation and then every 400 hours. Use 20W-50 engine oil with an SL API classification. 1. P lace container under oil f ilter to catch oil.
GB - 27 Short T erm Storage IMPORT ANT : NEVER clean unit with high- pressure wa ter or store unit outdoors. Remove all dirt, greas e, leaves, etc. Store in a clean dry area . Inspect unit for s igns of wear or damage. Ensure all fasteners are properly t ightened.
GB - 28 Engine r uns rough. 1. Choke engaged. 1. Disengage choke. 2. Air filter cartridge plugged. 2. Clean or replace air filter c artridge. Refer to Engine Manual for detailed instructions. 3. Faulty engine. 3. Contact your Ariens Dealer. Unit do es not move with engi ne r unni ng when u sing steering levers.
GB - 29 Unit do es not travel in a strai ght lin e. 1. Incorrect tire pressure. 1. Chec k tire pressu re ( see SPEC IFICATIONS on page 30) 2. Steering leve rs need adjustment. 2. Adjust steering levers (see Forward and Reverse S peed Adjustment on page 24) 3.
GB - 30 SPECIFICA TIONS Mode l Numbe r 915163 915165 915167 Mode l Zoom XL 42 Zoom XL 48 Zoom XL 54 Engin e Kawasa ki FR651 Kawasaki F R691 Displacement - in. 3 (cc) 45.5 (746) Max Governed RPM (May be different from maxi mum RP M) 3600 + 0 3600 – 50 Speed Forward M ax.
CARB_EP A_2011 31 CALIFORNIA AND EPA (U NITED STATES ENVIRONME NTAL PROTECTION AGENCY) E VAPO RATIVE EMISSION CONTROL WARRANTY S TATEMENT YOUR W ARRANTY RIGHTS AND OBLIGA TIONS The CARB (Ca liforn ia .
CARB_EP A_2011 32 (4.) Repair or replac ement of a ny warr anted part under t he warr anty provis ions of this arti cle must be p erform ed at no charge to the own er at a n authori zed Ar iens, Gra vely , or Parke r service rep re sentati ve .
Con_Ride_201 1 33 T wo-Y ear Limited Lawn and Garden Con sumer Ride-On Wa r r a n t y Ariens C ompany (A riens) w arrants to th e ori ginal pu rchase r that Ariens, G ravel y and Coun tax brand consum.
Con_Ride_201 1 34 T o f ind an A riens or Grav ely author ized ser vice repr esentative, contact Arie ns at: 655 W. Ryan Street Brillion, WI 541 10 (920) 7 56 - 46 88 www .
.
Ariens Company 655 West Ryan St reet Brillion, W I 541 10-1072 920-756-4688 Fax 920-756-2407 www .ariens.com.
Un point important après l'achat de l'appareil (ou même avant l'achat) est de lire le manuel d'utilisation. Nous devons le faire pour quelques raisons simples:
Si vous n'avez pas encore acheté Ariens 915165 c'est un bon moment pour vous familiariser avec les données de base sur le produit. Consulter d'abord les pages initiales du manuel d'utilisation, que vous trouverez ci-dessus. Vous devriez y trouver les données techniques les plus importants du Ariens 915165 - de cette manière, vous pouvez vérifier si l'équipement répond à vos besoins. Explorant les pages suivantes du manuel d'utilisation Ariens 915165, vous apprendrez toutes les caractéristiques du produit et des informations sur son fonctionnement. Les informations sur le Ariens 915165 va certainement vous aider à prendre une décision concernant l'achat.
Dans une situation où vous avez déjà le Ariens 915165, mais vous avez pas encore lu le manuel d'utilisation, vous devez le faire pour les raisons décrites ci-dessus,. Vous saurez alors si vous avez correctement utilisé les fonctions disponibles, et si vous avez commis des erreurs qui peuvent réduire la durée de vie du Ariens 915165.
Cependant, l'un des rôles les plus importants pour l'utilisateur joués par les manuels d'utilisateur est d'aider à résoudre les problèmes concernant le Ariens 915165. Presque toujours, vous y trouverez Troubleshooting, soit les pannes et les défaillances les plus fréquentes de l'apparei Ariens 915165 ainsi que les instructions sur la façon de les résoudre. Même si vous ne parvenez pas à résoudre le problème, le manuel d‘utilisation va vous montrer le chemin d'une nouvelle procédure – le contact avec le centre de service à la clientèle ou le service le plus proche.
