Manuel d'utilisation / d'entretien du produit 36 du fabricant Hearth and Home Technologies
Aller à la page of 44
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K • 7/1 1 1 Owner ’ s Manual Installation and Operation Models: Montana-36 Montana-42 Woodburning Fireplace DO NOT DISCARD THIS MANUAL CAUTION • Important operating and maintenance instructions included.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K 7/1 1 2 Read this manual before installing or operating this replace. Please retain this owner ’ s manual for future reference. Congratulations on selecting a Outdoor Lifestyles wood burning replace.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K • 7/1 1 3 T able of Contents 1 Listing and Code Approvals A. Appliance Certication . . . . . . . . . . . . . . . . . . . . . . . . . 4 2 Getting Started A.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K 7/1 1 4 1 Listing and C od e Appro vals A. Appliance Certication This replace system has been tested and listed in accor- dance with UL 127 and CAN/ULC-S610-M87 standards by Underwriters Laboratories Inc.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K • 7/1 1 5 2 Get ting Star t ed A. Design and Installation Considerations Draft is the pressure difference needed to vent replaces successfully .
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K 7/1 1 6 Before beginning the installation be sure the following tools and building supplies are availab.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K • 7/1 1 7 3 F raming and Clearances A. Selecting Fireplace Location This outdoor replace will shed moderate amounts of water , but is not waterproof.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K 7/1 1 8 B A H F Note: If this surface is inside the building’s warm air envelope... ...then this surface must be an exterior wall system. C D G G C D H G F J I E Figure 3.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K • 7/1 1 9 0 in. 0 in. to level of standoffs Combustible Object 36 in. (914 mm) 1-1/2 in. (38 mm) Drywall 0 in. 1/2 in. (13 mm) 1-1/2 in. (38 mm) B. Clearances Figure 3.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K 7/1 1 10 2 in./51 mm minimum air space clearance to the enclosure. Use only noncombustible material below the top of the top standoffs. 28-3/8 in. 721 cm 74-1/2 in.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K • 7/1 1 1 1 E. Chimney Requirements When planning your replace location, the chimney construc- tion and necessary clearances must be considered.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K 7/1 1 12 72 in./183 cm min. TR1 1/TR444 T ermination Cap A. Install the Dual Cooling Air Kit The cooling air kit is supplied as a standard feature with this replace and is required for safe operation.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K • 7/1 1 13 B. Secure the Fireplace • Position the Fireplace This replace may be placed on either a combustible or noncombustible continuous at surface.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K 7/1 1 14 A. Chimney Requirements V ertical distances are measured from the base of the re- place. • Minimum overall straight height is 6 ft 4 in. if the replace is fre est andi ng and a min imu m of 10 ft fro m a comb ust ibl e structure.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K • 7/1 1 15 B. Using Offsets/Returns T o bypass any overhead obstructions, the chimney may be offset using an of fset/return. An offset and return may be attached together or a chimney section(s) may be used between an offset and return.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K 7/1 1 16 C. Assemble the Chimney Sections Attach either a straight chimney section or an offset to the top of the replace (depending on your installation require- ment).
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K • 7/1 1 17 E. Install the Attic Insulation Shield An insulation shield must be installed when there is a pos- sibility of insulation coming into contact with the factory built chimney system.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K 7/1 1 18 6 Complete the Enclosure Figure 6.1 Multiple Chimneys A.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K • 7/1 1 19 T ermination Cap Storm Collar Slope Downward T urn-down Drip Edge Chase (Chimney) 2 in. (51 mm) Collar on Chase T op Caulk .018 (26 ga) min. Galvanized Chase T op Figure 6.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K 7/1 1 20 Not e : T o protect against the ef fect of cor rosio n on t hose par ts exposed to the weather , t he ter mination cap can be painted with a r ust-resist ant paint.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K • 7/1 1 21 • TCT1 175 T erra Cotta Cap Chimney Pipe Chase T op T ermination Cap Chase Collar 2 in. (51 mm) Minimum Height Remove 2 screws from front & back to lift the top off T ermination cap pipe and chimney section must overlap 1-1/2 in.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K 7/1 1 22 A. Gas Log/Lighter Provisions A certied gas log lighter or decorative gas log set can be installed in this replace. This replace was not tested and listed for use with an un- vented gas log heater .
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K • 7/1 1 23 8 F inishing A. Hearth Extension A hearth extension must be installed with all replaces to protect the combustible oor in front of the replace from both radiant heat and sparks.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K 7/1 1 24 B. Finishing Material • Combustible Material Material which is made of or surfaced with wood.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K • 7/1 1 25 9 Operat ing Instruct ions A. General Information Fireplaces, as well as other woodburning appliances, have been used safely for many years.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K 7/1 1 26 D. Flue Damper The ue damper must be in full open position, and is oper- ated by moving the handle up toward the top of the replace. Before lighting the re, verify this by looking up from the in- side of the replace.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K • 7/1 1 27 G. Grate The factory installed integral grate must be used to hold the logs from falling out of an open replace and to allow air to pass between the burning logs.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K 7/1 1 28 I. Starting a Fire Check the ue damper to be certain it is in the full open po- sition. Place crumpled or twisted paper under the replace grate.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K • 7/1 1 29 Diagnostics and Problem Solving 1 0 T roubleshooting I can’t get a good re going. What am I doing wrong? Diagnostic Questions Possible Causes of Condition Solutions Is the damper open? • No draft Open damper .
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K 7/1 1 30 A. Disposal of Ashes Ashes should be placed in a metal container with a tight-t- ting lid.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K • 7/1 1 31 Fire Risk • Do not use chimney cleaners or ame colorants in your replace. Will corrode chimney . W ARNING D. Maintenance T ask List Asphyxiation Risk Fire Risk Annual inspection by qualified technician recommended.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K 7/1 1 32 1 2 Reference Materials A. Fireplace Dimensions C 23 in.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K • 7/1 1 33 B. Fireplace Components Bi-fold Glass Doors Herringbone Pattern Refractory T raditional Brick Pattern Refractory 20 in. (508 mm) 66 in. (1676 mm) 1/2 in.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K 7/1 1 34 C. Chimney Components The following pictures show only those chimney components which may be safely used with this replace. 13 in. (330 mm) 14 in.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K • 7/1 1 35 A B 17 in. (432 mm) Ceiling Firestop Assembled Diameter: 17 in./432 mm Height: 24 in./610 mm AS10 Straight Attic Insulation Shield 2 in. (51 mm) 13 in.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K 7/1 1 36 72 in. (1829 mm) 36 in. (914 mm) 2 in. (51 mm) 13-3/8 in. (340 mm) CT56 Chase T op A B C D LDS33/LDS46 Decorative Shroud TR1 1/TR444 Round T ermination Cap 15-3/4 in.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K • 7/1 1 37 Woodburning T ermination Cap Shroud TS345/T445 (T op V ent) TR342/TR344 TR442/TR444 TV342 .
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K 7/1 1 38 D. Service Parts Service Parts 06/1 1 36” Outdoor Woodburning Fireplace 2 1 3 4 5 6 8 9 10 1 1 12 13 14 15 16 17 7 Part number list on following page.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K • 7/1 1 39 D. Service Parts (continued) Service Parts 06/1 1 42” Outdoor Woodburning Fireplace 2 1 3 4 5 6 8 9 10 1 1 12 13 14 15 16 17 7 MONT ANA-42, MONT ANA-42H Part number list on following page.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K 7/1 1 40 This page intentionally left blank..
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K • 7/1 1 41 This page intentionally left blank..
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K 7/1 1 42 E. Limited W arranty Outdoor Lifestyles by Hearth & Home T echnologies, Inc.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K • 7/1 1 43 Limited W arranty (continued) • Damages resulting from: (1) failure to install, operate,.
Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K 7/1 1 44 – NOTES – F . Contact Information DO NOT DISCARD THIS MANUAL CAUTION • Important operating and maintenance instructions included. • Leave this manual with party responsible for use and operation.
Un point important après l'achat de l'appareil (ou même avant l'achat) est de lire le manuel d'utilisation. Nous devons le faire pour quelques raisons simples:
Si vous n'avez pas encore acheté Hearth and Home Technologies 36 c'est un bon moment pour vous familiariser avec les données de base sur le produit. Consulter d'abord les pages initiales du manuel d'utilisation, que vous trouverez ci-dessus. Vous devriez y trouver les données techniques les plus importants du Hearth and Home Technologies 36 - de cette manière, vous pouvez vérifier si l'équipement répond à vos besoins. Explorant les pages suivantes du manuel d'utilisation Hearth and Home Technologies 36, vous apprendrez toutes les caractéristiques du produit et des informations sur son fonctionnement. Les informations sur le Hearth and Home Technologies 36 va certainement vous aider à prendre une décision concernant l'achat.
Dans une situation où vous avez déjà le Hearth and Home Technologies 36, mais vous avez pas encore lu le manuel d'utilisation, vous devez le faire pour les raisons décrites ci-dessus,. Vous saurez alors si vous avez correctement utilisé les fonctions disponibles, et si vous avez commis des erreurs qui peuvent réduire la durée de vie du Hearth and Home Technologies 36.
Cependant, l'un des rôles les plus importants pour l'utilisateur joués par les manuels d'utilisateur est d'aider à résoudre les problèmes concernant le Hearth and Home Technologies 36. Presque toujours, vous y trouverez Troubleshooting, soit les pannes et les défaillances les plus fréquentes de l'apparei Hearth and Home Technologies 36 ainsi que les instructions sur la façon de les résoudre. Même si vous ne parvenez pas à résoudre le problème, le manuel d‘utilisation va vous montrer le chemin d'une nouvelle procédure – le contact avec le centre de service à la clientèle ou le service le plus proche.
