Manuel d'utilisation / d'entretien du produit VFRMV24PA du fabricant Desa
Aller à la page of 32
Sav e this manual for future reference. For more information, visit www .desatech.com W ARNING: If the information in this manual is not fol- lowed exactly , a fire or explosion may result causing property damage, personal injury or loss of life.
www .desatech.com 1 14745-01B 2 W ARNING: Improper installation, adjustment, altera- tion, service or maintenance can cause injury or prop- erty damage. Refer to this manual for correct installation and operational procedures. For assistance or addi- tional information consult a qualified installer , service agency or the gas supplier .
www .desatech.com 1 14745-01B 3 SAFETY INFORMA TION IMPORT ANT : Read this owner ’ s man ual care ful ly and compl etel y before trying to assemble, op- erate or service this log set. Improper use of this log set can cause serious injury or death from burns, fire, explosion, electrical shock and carbon monoxide poisoning.
www .desatech.com 1 14745-01B 4 Keep the appliance area clear and free from combustible ma- terials, gasoline and other flam- mable vapors and liquids.
www .desatech.com 1 14745-01B 5 PRODUCT IDENTIFICA TION Figure 1 - Product Identification Log Set Chassis Assembly Lava Rock LOCAL CODES Install and use the heater with care. Follow all local codes. In the absence of local codes, use the latest edition of the National Fuel Gas Code ANSI Z223.
www .desatech.com 1 14745-01B 6 AIR FOR COMB USTION AND VENTILA TION W ARNING: This heater shall not be installed in confined space or unusually tight con- struction unless provisions are provided for adequate combus - tion and ventilation air .
www .desatech.com 1 14745-01B 7 1. Determine the volume of the space (length x width x height). Length x Width x Height = ________ cu. ft. (volume of space) Example: Space size 20 ft.
www .desatech.com 1 14745-01B 8 V entilation Air From Outdoors Prov ide extra fresh air by using ventilat ion grills or ducts. Y ou must provide two permanent openings: one within 12" of the ceiling and one within 12" of the floor . Connect these items directly to the outdoors or spaces open to the outdoors.
www .desatech.com 1 14745-01B 9 W ARNING: Seal any fresh air vents or ash clean-out doors located on floor or wall of fire- place. If not, drafting may cause pilot outage or sooting.
www .desatech.com 1 14745-01B 10 NOTICE: Non thermostat con- trolled heaters may be used as a vented product. If so, you must always run heater with chimney flue damper open and damper cla mp inst al led . If r unn ing h eat er with damper open, noncombus- tible mat erial abo ve th e fir eplac e opening is not needed.
www .desatech.com 1 14745-01B 1 1 MANTEL CLEARANCES In addition to meeting noncombustible material clea ranc es, you must also meet requir ed clearan ces between fireplace opening and mantel shelf. If you do not meet the clearances listed below , you will need a hood.
www .desatech.com 1 14745-01B 12 INST ALLA TION Continued INST ALLING DAMPER CLAMP ACCESSOR Y FOR VENTED OPERA TION Not e: Whe n used as a ven ted deco rat ive, app lian ce must be installed only in a solid-fuel burning fireplace with a working flue and constructed of noncombustible material.
www .desatech.com 1 14745-01B 13 INST ALLA TION Continued Note: Install optional GHRCTB Receiver and Hand-Held Remote Control Kit (see Accessories , page 26) before installing gas log heater . See in - stallation instructions included with the kit. 1 .
www .desatech.com 1 14745-01B 14 Installation must include an equipment shutoff va lv e, unio n an d plu gg ed 1/8 " NPT tap . Lo ca te NP T tap within reac h fo r tes t gau ge hook up.
www .desatech.com 1 14745-01B 15 PRESSURE TESTING GAS SUPPL Y PIPING SYSTEM T est Pressures In Excess Of 1/2 PSIG (3.5 kPa) 1. Disconnect appliance with its appliance main gas valve (control valve) and equipment shutoff valve from gas supply piping system.
www .desatech.com 1 14745-01B 16 OPERA TING HEA TER FOR YOUR SAFETY READ BEFORE LIGHTING W ARNING: If you do not fol- low these instructions exactly , a fire or explosion may result causing property damage, per- sonal injury or loss of life. A. This appliance has a pilot which must be lighted by hand.
www .desatech.com 1 14745-01B 17 W ARNING: Burners will come on automatically within one minute when the switch is in the ON position after the pilot is lit. 5. W ait five (5) minutes to clear out any gas. Then smell for gas, including near the floor .
www .desatech.com 1 14745-01B 18 OPERA TING HEA TER Continued MANUAL LIGHTING PROCEDURE 1. Follow steps 1 through 6 under Lighting Instructions , page 16. 2. Depress control knob and light pilot with match. 3. Keep cont ro l knob pres sed in for 30 seco nds afte r lighti ng pilot.
www .desatech.com 1 14745-01B 19 Figure 21 - Thermostat Hand-Held Remote Control Unit (GHRCTB) T urns Hand- Held Remote On or Off and Allows Y ou to Choose the Manual Setting Selects Auto Setting Incr.
www .desatech.com 1 14745-01B 20 INSPECTING B URNERS Continued BURNER FLAME P A TTERN Figure 24 shows correct burner flame pattern. NOTICE: Do not mistake orange flames with yellow tipping. Dirt or other fine par ticl es ar e b urned by heater , causing brief patches of orange flame.
www .desatech.com 1 14745-01B 21 1. Shut off the unit, including the pilot. Allow the unit to cool for at least thirty minutes. 2. In spec t b urne r , pi lot an d p rima ry air in let opening on injector holder for dust and dirt (see Figure 26). 3. Blow air through the ports/slots and holes in the burner .
www .desatech.com 1 14745-01B 22 TROUBLESHOO TING W AR NIN G: T urn off and unp lug hea ter and let coo l bef or e ser vi ci ng . Only a qualified service person should service and repair heater . CAUTION: Never use a wire, needle or similar object to clean ODS/pilot.
www .desatech.com 1 14745-01B 23 POSSIBLE CAUSE 1. C o n tr ol k no b n o t f u ll y pr es se d i n 2. Control knob not pressed in long enough 3. Safety interlock system has been triggered 4.
www .desatech.com 1 14745-01B 24 POSSIBLE CAUSE 1. Not enough air 2. Gas regulator defective 1. Resid ues from manufa ctur ing processes and logs curing 1. Turning control knob to HI position when burners are cold 2. Air in gas line 3. Air passageways on heater blocked 4.
www .desatech.com 1 14745-01B 25 W ARNING: If you smell gas • Shut off gas supply . • Do not try to light any appliance. • Do not touch any electrical switch; do not use any phone in your building. • Immediately call your gas supplier from a neighbor ’s phone.
www .desatech.com 1 14745-01B 26 SPECIFICA TIONS VFRMV18NA VFRMV24NA VFRMV18P A VFRMV24P A Btu (V ariable) 24,000/36,000 28,000/39,000 26,000/34,000 31,000/39,000 T ype Gas Natural Gas Only Natural Gas Only Propane/LP Only Propane/LP Only Ignition Piezo Piezo Piezo Piezo Manifold Pressure 3.
www .desatech.com 1 14745-01B 27 W ALL-MOUNT THERMOST A T SWITCH - GWMT1 (Not Shown) For all models. The desired comfort setting can be selected on the wall thermostat and the log heater will automatically cycle from pilot to the heat setting selected.
www .desatech.com 1 14745-01B 28 ILL USTRA TED P ARTS BREAKDOWN VFRMV18NA, VFRMV18P A VFRMV24NA ( Shown), VFRMV24P A 1 2 3 4 6 7 8 9 10 1 1 12 13 14 15 16 17 18 19 20 21 22 23 24 24 24 24 24 24 24 5 2.
www .desatech.com 1 14745-01B 29 P ARTS LIST This list contains replaceable parts used in your heater . When ordering parts, follow the instructions listed under Replacement Parts on page 26 of this manual. KEY P ART NUMBER NO. VFRMV18NA VFRMV24NA VFRMV18P A VFRMV24P A DESCRIPTION QTY .
www .desatech.com 1 14745-01B 30 _____________________________________________________ ______________________________________________________ ______________________________________________________ ___.
www .desatech.com 1 14745-01B 31 _____________________________________________________ ______________________________________________________ ______________________________________________________ ___.
2701 Industrial Drive P .O. Box 90004 Bowling Green, KY 42102-9004 www .desatech.com NOT A UPC WARRANTY INFORMA TION KEEP THIS WARRANTY Model Serial No. Date Purchased 1 14745-01 Rev . B 10/04 Always specify model and serial numbers when communicating with the factory .
Un point important après l'achat de l'appareil (ou même avant l'achat) est de lire le manuel d'utilisation. Nous devons le faire pour quelques raisons simples:
Si vous n'avez pas encore acheté Desa VFRMV24PA c'est un bon moment pour vous familiariser avec les données de base sur le produit. Consulter d'abord les pages initiales du manuel d'utilisation, que vous trouverez ci-dessus. Vous devriez y trouver les données techniques les plus importants du Desa VFRMV24PA - de cette manière, vous pouvez vérifier si l'équipement répond à vos besoins. Explorant les pages suivantes du manuel d'utilisation Desa VFRMV24PA, vous apprendrez toutes les caractéristiques du produit et des informations sur son fonctionnement. Les informations sur le Desa VFRMV24PA va certainement vous aider à prendre une décision concernant l'achat.
Dans une situation où vous avez déjà le Desa VFRMV24PA, mais vous avez pas encore lu le manuel d'utilisation, vous devez le faire pour les raisons décrites ci-dessus,. Vous saurez alors si vous avez correctement utilisé les fonctions disponibles, et si vous avez commis des erreurs qui peuvent réduire la durée de vie du Desa VFRMV24PA.
Cependant, l'un des rôles les plus importants pour l'utilisateur joués par les manuels d'utilisateur est d'aider à résoudre les problèmes concernant le Desa VFRMV24PA. Presque toujours, vous y trouverez Troubleshooting, soit les pannes et les défaillances les plus fréquentes de l'apparei Desa VFRMV24PA ainsi que les instructions sur la façon de les résoudre. Même si vous ne parvenez pas à résoudre le problème, le manuel d‘utilisation va vous montrer le chemin d'une nouvelle procédure – le contact avec le centre de service à la clientèle ou le service le plus proche.
