Manuel d'utilisation / d'entretien du produit CG10N du fabricant Desa
Aller à la page of 26
Save this manual for future reference. BLUE FLAME VENT -FREE N A TURAL GAS HEA TER OWNER’S OPERA TION AND INST ALLA TION MANUAL CG6N CG10N CGS10N 10,000 and 6,000 Btu/Hr Thermostat and Non-Thermosta.
2 107294 NA TURAL GAS HEA TER SAFETY INFORMA TION WARNINGS IMPORTANT: Read this owner’s manual carefully and completely before trying to assemble, oper- ate, or service this heater. Im- proper use of this heater can cause serious injury or death from burns, fire, explosion, and car- bon monoxide poisoning.
3 107294 OWNER’S MANUAL PRODUCT IDENTIFICA TION Figure 1 - Vent-Free Natural Gas Heater (Model CGS10N Shown) Control Knob Heater Cabinet Grill Guard Glass Panel Front Panel LOCAL CODES Install and use heater with care. Follow all local codes. In the absence of local codes, use the latest edition of The National Fuel Gas Code ANS Z223.
4 107294 NA TURAL GAS HEA TER AIR FOR COMBUSTION AND VENTILA TION WARNING: This heater shall not be installed in a confined space or unusually tight construction unless provisions are provided for adequate combustion and ven- tilation air.
5 107294 OWNER’S MANUAL WARNING: If the area in which the heater may be operated is smaller than that defined as an unconfined space or if the building is of unusually tight construction, provide adequate combustion and ventilation air by one of the methods described in the National Fuel Gas Code, ANS Z223.
6 107294 NA TURAL GAS HEA TER AIR FOR COMBUSTION AND VENTILA TION Continued Figure 2 - Ventilation Air from Inside Building Figure 3 - Ventilation Air from Outdoors Ventilation Air From Outdoors Provide extra fresh air by using ventilation grills or ducts.
7 107294 OWNER’S MANUAL For convenience and efficiency, install heater • where there is easy access for operation, inspection, and service • in coldest part of room Figure 4 - Mounting Clearance.
8 107294 NA TURAL GAS HEA TER INST ALLA TION Continued Attaching Mounting Bracket To Wall Note: Wall anchors, mounting screws, and spacers are in hardware package. The hard- ware package is provided with heater. Attaching To Wall Stud Method For attaching mounting bracket to wall studs 1.
9 107294 OWNER’S MANUAL Tee Joint Reducer Bushing to 1/8" NPT 1/8" NPT Plug Tap Figure 13 - Gas Connection * A CSA/AGA design-certified equipment shutoff valve with 1/8" NPT tap is an acceptable alternative to test gauge connection. Purchase the optional CSA/AGA design-certified equipment shutoff valve from your dealer.
10 107294 NA TURAL GAS HEA TER Gas Meter Control Valve Location Equipment Shutoff Valve CHECKING GAS CONNECTIONS WARNING: Test all gas pip- ing and connections for leaks after installation or servicing. Correct all leaks at once. WARNING: Never use an open flame to check for a leak.
11 107294 OWNER’S MANUAL TO TURN OFF GAS TO APPLIANCE 1. Remove fr ont panel (see Figure 7, page 8). 2. Follow steps 1 thr ough 5 under Light- ing Instructions . 3. With contr ol knob pr essed in, str ike match. Hold match to pilot until pi- lot lights.
12 107294 NA TURAL GAS HEA TER THERMOSTAT MODEL CGS10N FOR YOUR SAFETY READ BEFORE LIGHTING A. This appliance has a pilot which must be lighted by hand. When lighting the pilot, follo w these instructions exactly . B . BEFORE LIGHTING smell all around the appliance ar ea for gas.
13 107294 OWNER’S MANUAL BURNER FLAME PATTERN Figure 22 shows a correct burner flame pattern. Figure 23 shows an incorrect burner flame pattern. The incorrect burner flame pattern shows yellow tipping of the flame. It also shows the flame higher than 1/2 the glass panel height.
14 107294 NA TURAL GAS HEA TER Note: All troubleshooting items are listed in order of operation. TROUBLESHOOTING WARNING: Turn off heater and let cool before servicing. Only a qualified service person should service and repair heater. POSSIBLE CAUSE 1.
15 107294 OWNER’S MANUAL OBSERVED PROBLEM Burner does not light after ODS/pilot is lit Delayed ignition of burner Burner backfiring during combustion Yellow flame during burner combustion Slight smo.
16 107294 NA TURAL GAS HEA TER TROUBLESHOOTING Continued WARNING: If you smell gas • Shut off gas supply. • Do not try to light any appliance. • Do not touch any electrical switch; do not use any phone in your building. • Immediately call your gas supplier from a neighbor’s phone.
17 107294 OWNER’S MANUAL CG10N CG6N CGS10N Btu (Variable) 5,000/10,000 4,400/6,000 5,000/10,000 Type Gas Natural Only Natural Only Natural Only Ignition Piezo Piezo Piezo Pressure Regulator Setting 3" W.C. 3" W.C. 3" W.C. Inlet Gas Pressure (inches of water) Maximum 10.
18 107294 NA TURAL GAS HEA TER Note: Use only original replacement parts. This will protect your warranty coverage for parts replaced under warranty. PARTS UNDER WARRANTY Contact authorized dealer from whom you purchased this product.
19 107294 OWNER’S MANUAL Baltimore Electric 1348 Dixwell Avenue Hamden, CT 06514-0322 1-800-397-7553 203-248-7553 Parts Department Portable Heater Parts 342 N. County Rd. 400 East Valparaiso, IN 46383-9704 All States 219-462-7441 1-800-362-6951 sales@portableheaterparts.
20 107294 NA TURAL GAS HEA TER 7 7 29 2 3 29 28 23 27 24 20 18 25 26 10 27 22 21 19 17 16 13 1 14 15 7 11 12 30 4 5 7 6 7 7 19 17 8 18 9 CG10N 25-2 25-1 ILLUSTRA TED P ARTS LIST ODS Pilot Assembly.
21 107294 OWNER’S MANUAL P ARTS LIST CG10N This list contains replaceable parts used in your heater. When ordering parts, follow the instructions listed under Replacement Parts on page 18 of this manual.
22 107294 NA TURAL GAS HEA TER CG6N 25-2 25-1 ILLUSTRA TED P ARTS LIST ODS Pilot Assembly 7 7 29 2 3 29 28 23 27 24 20 18 25 26 10 27 22 21 19 17 16 13 1 14 15 7 11 12 30 4 5 7 6 7 7 19 17 8 18 9.
23 107294 OWNER’S MANUAL P ARTS LIST CG6N This list contains replaceable parts used in your heater. When ordering parts, follow the instructions listed under Replacement Parts on page 18 of this manual.
24 107294 NA TURAL GAS HEA TER CGS10N 27-2 27-1 ILLUSTRA TED P ARTS LIST ODS Pilot Assembly 7 7 14 2 3 14 12 25 10 26 22 20 27 28 13 10 24 23 21 19 15 1 16 17 7 18 4 5 7 6 7 7 8 11 11 20 21 19 29 9.
25 107294 OWNER’S MANUAL P ARTS LIST CGS10N This list contains replaceable parts used in your heater. When ordering parts, follow the instructions listed under Replacement Parts on page 18 of this manual.
KEEP THIS WARRANTY W ARRANTY INFORMA TION Always specify model and serial numbers when communicating with the factory. We reserve the right to amend these specifications at any time without notice. The only warranty applicable is our standard written warranty.
Un point important après l'achat de l'appareil (ou même avant l'achat) est de lire le manuel d'utilisation. Nous devons le faire pour quelques raisons simples:
Si vous n'avez pas encore acheté Desa CG10N c'est un bon moment pour vous familiariser avec les données de base sur le produit. Consulter d'abord les pages initiales du manuel d'utilisation, que vous trouverez ci-dessus. Vous devriez y trouver les données techniques les plus importants du Desa CG10N - de cette manière, vous pouvez vérifier si l'équipement répond à vos besoins. Explorant les pages suivantes du manuel d'utilisation Desa CG10N, vous apprendrez toutes les caractéristiques du produit et des informations sur son fonctionnement. Les informations sur le Desa CG10N va certainement vous aider à prendre une décision concernant l'achat.
Dans une situation où vous avez déjà le Desa CG10N, mais vous avez pas encore lu le manuel d'utilisation, vous devez le faire pour les raisons décrites ci-dessus,. Vous saurez alors si vous avez correctement utilisé les fonctions disponibles, et si vous avez commis des erreurs qui peuvent réduire la durée de vie du Desa CG10N.
Cependant, l'un des rôles les plus importants pour l'utilisateur joués par les manuels d'utilisateur est d'aider à résoudre les problèmes concernant le Desa CG10N. Presque toujours, vous y trouverez Troubleshooting, soit les pannes et les défaillances les plus fréquentes de l'apparei Desa CG10N ainsi que les instructions sur la façon de les résoudre. Même si vous ne parvenez pas à résoudre le problème, le manuel d‘utilisation va vous montrer le chemin d'une nouvelle procédure – le contact avec le centre de service à la clientèle ou le service le plus proche.
