Manuel d'utilisation / d'entretien du produit 463268008 du fabricant Char-Broil
Aller à la page of 32
THIS GRILL IS FOR OUTDOOR USE ONL Y . If you have questions or need assistance during assembly , please call . T o insure your satisfaction and for follow-up service, register your grill online at www.
WARNING CALIFORNIA PROPOSITION 65 1. Combustion by-products produced when using this product contain chemicals known to the State of California to cause cancer, birth defects, and other reproductive harm.
T ABLE OF CONTENTS F o r Y o u r S a f e t y ......................................2 G r i l l S e r v i c e C e n t e r ...................................2 P r o d u c t R e c o r d I n f o r m a t i o n ............................2 Installation Safety Precautions .
• NEVER store a spare LP cylinder under or near the appliance or in an enclosed area. • Never fill a cylinder beyond 80% full. • An over filled or improperly stored cylinder is a hazard due to possible gas release from the safety relief valve. This could cause an intense fire with risk of property damage, serious injury or death.
WARNING If “growing” bubbles appear do not use or move the LP cylinder . Contact an LP gas supplier or your fire department! Connecting Regulator to the LP Cylinder 1. LP cylinder must be properly secured onto grill. (Refer to assembly section.) 2.
6. T urn the coupling nut clockwise and tighten to a full stop. The regulator will seal on the back-check feature in the LP cylinder valve, resulting in some resistance. An additional one-half to three-quarters turn is required to complete the connection.
WARNING For Safe Use of Your Grill and to Avoid Serious Injury: • Do not let children operate or play near grill. • Keep grill area clear and free from materials that burn. • Do not block holes in sides or back of grill. • Check burner flames regularly .
Burner Flame Check • Remove cooking grates and flame tamers. Light burners, rotate knobs from HIGH to LOW . Y ou should see a smaller flame in LOW position than seen on HIGH. Perform burner flame check on sideburner , also. Always check flame prior to each use.
Cleaning the Burner Assembly Follow these instructions to clean and/or replace parts of burner assembly or if you have trouble igniting grill. 1. Turn gas off at control knobs and LP cylinder. 2. Remove cooking grates and flame tamers. 3. Remove screws and carryover tubes from rear of burners.
Indirect Cooking Poultry and large cuts of meat cook slowly to perfection on the grill by indirect heat. The heat from selected burners circulates gently throughout the grill, cooking meat or poultry without the touch of a direct flame.
463268008 • 1 1 CARE AND CLEANING OF YOUR ST AINLESS STEEL GRILL Routine cleaning is necessary to preserve the appearance and corrosion resistance of Stainless Steel. The perception that many people have is that stainless steel will not rust. That is not the case in certain conditions.
PREVENTIVE MAINTENANCE Routine care Grill fires are common when grease and food debris collect in the bottom of the grill. Periodic cleaning of the grill bottom and grill burner radiant is needed to prevent grease fires. A common misconception is to clean your grill by the "burn off" method.
P ARTS LIST – Model No. 463268008 Key Qty Description Part # A 1 Bottom Shelf . . . . . . . . . . . . . . . . . . . . . 80013428 B 2 Locking Caster . . . . . . . . . . . . . . . . . . . 80000268 C 2 Fixed Caster . . . . . . . . . . . . . . . . . . .
P ARTS DIAGRAM – Model No. 463268008 MM SS LL KK RR QQ S W R BB D M TT GG Z N E EE FF L V I G U Y Y X X T NN OO Q O J UU K PP OO P H B C A B C HH II JJ 2 JJ 1 JJ 3 VV F DD TT CC AA 14 • 463268008.
2 1/4-20x1/2” screw ASSEMBL Y – Model No. 463268008 1 Attach side panels to bottom shelf using three 1/4-20x1/2” screws, 7mm lock washers, and 7mm flat washers per panel.
3 4 This step requires two people to lift and position grill head onto cart. Carefully lower the grill head onto the cart, aligning slots at bottom of grill head with posts on cart side panels. Make sure the regulator hose is hanging outside the cart.
Front brace 6 On back of grill, place upper back panel between side panels and above lower back panel. Secure upper back panel, in lower holes, using one 1/4-20x1½” screw , 7mm lock washer , and 7mm flat washer on each side. Do not fully tighten screws until side shelf installation is complete in later steps.
7 8 Insert tabs on right side shelf into rectangular slots in side of firebox. Attach rear of shelf using one 1/4-20x3/4” screw , 7mm lock washer , and 7mm flat washer in upper hole. Use one 1/4-20x1½” screw , 7mm lock washer , and 7mm flat washer in lower hole.
Burner tube Valve 9 10 First, remove the two screws and lock washers factory attached to the sideburner valve bracket. Position sideburner valve bracket beneath sideburner shelf fascia so that valve stem comes through larger center hole in fascia. Align the holes on valve bracket with left and right holes on fascia.
12 11 Under sideburner shelf, attach sideburner ignitor wire to electrode (A) . Place burner cap onto sideburner . Attach sideburner cap clip (B) . Place sideburner grate onto sideburner shelf, aligning grate legs with holes in shelf.
13 14 Insert hinge pin on bottom of doors into hole in bottom shelf. Press upper hinge pin in front brace, align hinge hole on top of door , and release hinge pin into door .
Place cooking grates onto the firebox as shown. Insert the three wire ends at rear of warming rack into holes in back of firebox. Front wires of warming rack rest on sides of firebox. Assembled warming rack Warming rack Cooking grate 15 16 LP CYLINDER IS SOLD SEPARATELY.
On back of grill, slide grease tray into opening in upper back panel. CA UTION Failure to install grease tray will cause hot grease to drip from bottom of grill with risk of fire or property damage. Grease tray Unscrew electronic ignition button on front of control panel.
EMERGENCIES: If a gas leak cannot be stopped, or a fire occurs due to gas leakage, call the fire department. Emergencies Problem Gas leaking from cracked/cut/burned hose. Gas leaking from LP cylinder . Gas leaking from LP cylinder valve. Gas leaking between LP cylinder and regulator connection.
Troubleshooting ( continued ) Problem Burner(s) will not light using ignitor . (See Electronic Ignition T roubleshooting also) Burner(s) will not match light. Sudden drop in gas flow or low flame. Flames blow out. Flare-up. Persistent grease fire. Flashback.
Troubleshooting - Electronic Ignition Problem (Ignition) SECTION I No sparks appear at any electrodes when ignition button is pushed; no noise can be heard from spark module. SECTION II No sparks appear at any electrodes when ignition switch is pushed; noise can be heard from spark module.
463268008 • 27 This page intentionally blank.
Manufacturer warrants to the original consumer-purchaser only that this product shall be free from defects in workmanship and materials after correct assembly and under normal and reasonable home use for the periods indicated below beginning on the date of purchase.
463268008 • 29 This page intentionally blank.
Mail to: / Envíelo a: Consumer W arranty Service P . O. Box 1240 Columbus, GA 31902-1240 Thank you for completing this questionnaire. Y our answers will help us and other companies reach you with of fers that may interest you. If you prefer not to receive these offers, please check here .
463268008 • 31 This page intentionally blank.
Char-Broil, LLC Printed in China • 2007 Columbus, GA 31902 • ST OP Should you encounter a problem with our product CALL US FIRST Do not return this product to the store. WE CAN HELP GRILL SERVICE CENTER 1-800-241-7548 HOURS 8AM-6PM EST Mon-Fri Please ensure your warranty registration is complete.
Un point important après l'achat de l'appareil (ou même avant l'achat) est de lire le manuel d'utilisation. Nous devons le faire pour quelques raisons simples:
Si vous n'avez pas encore acheté Char-Broil 463268008 c'est un bon moment pour vous familiariser avec les données de base sur le produit. Consulter d'abord les pages initiales du manuel d'utilisation, que vous trouverez ci-dessus. Vous devriez y trouver les données techniques les plus importants du Char-Broil 463268008 - de cette manière, vous pouvez vérifier si l'équipement répond à vos besoins. Explorant les pages suivantes du manuel d'utilisation Char-Broil 463268008, vous apprendrez toutes les caractéristiques du produit et des informations sur son fonctionnement. Les informations sur le Char-Broil 463268008 va certainement vous aider à prendre une décision concernant l'achat.
Dans une situation où vous avez déjà le Char-Broil 463268008, mais vous avez pas encore lu le manuel d'utilisation, vous devez le faire pour les raisons décrites ci-dessus,. Vous saurez alors si vous avez correctement utilisé les fonctions disponibles, et si vous avez commis des erreurs qui peuvent réduire la durée de vie du Char-Broil 463268008.
Cependant, l'un des rôles les plus importants pour l'utilisateur joués par les manuels d'utilisateur est d'aider à résoudre les problèmes concernant le Char-Broil 463268008. Presque toujours, vous y trouverez Troubleshooting, soit les pannes et les défaillances les plus fréquentes de l'apparei Char-Broil 463268008 ainsi que les instructions sur la façon de les résoudre. Même si vous ne parvenez pas à résoudre le problème, le manuel d‘utilisation va vous montrer le chemin d'une nouvelle procédure – le contact avec le centre de service à la clientèle ou le service le plus proche.
