Manuel d'utilisation / d'entretien du produit G4 du fabricant Cal Flame
Aller à la page of 28
.
Copyright 2008-2009 LMS, Inc. All rights reserved. Duplication without written consent is strictly prohibited. Cal Flame ® is a registered trademark. Due to continuous improvement programs, all models, operation, and/or specications are subject to change without prior notice.
Safety Instructions 1 2009 G3, G4, G5 Grills L TR20091050, Rev . A w w w . c a l s p a s . c o m Placement and Location Cal Flame grills are designed for outdoor use only. Never locate this appliance in an enclosed room, under a sealed • overhead structur e, or in an y type of enclosed area such as a garage, shed, or breez eway .
2 Safety Instructions 2009 G3, G4, G5 Grills L TR20091050, Rev . A w w w . c a l s p a s . c o m Before you start cooking, clean the entire grill thoroughly with hot, • soapy water . This is necessary to remov e residual solv ents, oil and grease used in the manufacturing process.
Safety Instructions 3 2009 G3, G4, G5 Grills L TR20091050, Rev . A w w w . c a l s p a s . c o m garments while using your grill. Fabric may ignite and result in personal injury . When using the grill, do not touch the grill rack, burner grate, or • immediate surr oundings as these areas become extremely hot and can cause burns.
4 Installation / Assembl y 2009 G3, G4, G5 Grills L TR20091050, Rev . A w w w . c a l s p a s . c o m Most cities and counties requir e permits for exterior construction and electrical circuits.
Installation / Assembl y 5 2009 G3, G4, G5 Grills L TR20091050, Rev . A w w w . c a l s p a s . c o m Cabinet Cut-out Dimensions Y our Cal Flame grill is designed for easy installation into a non- combustible enclosure. The supporting deck or counter must be at and level.
6 Installation / Assembl y 2009 G3, G4, G5 Grills L TR20091050, Rev . A w w w . c a l s p a s . c o m LP Gas Tank Requirements For plumbed-in LP instal lation, use a con vertible regulator and set it for LP gas. Maximum line pressur e for plumbed-in propane is 14” WC (3.
Installation / Assembl y 7 2009 G3, G4, G5 Grills L TR20091050, Rev . A w w w . c a l s p a s . c o m The maximum fuel capacity is 20 lbs. of propane, or 5 gal lons. Full cylinder weight should be approximately 38 lbs. (43.7 lbs. nominal water capacity .
8 Installation / Assembl y 2009 G3, G4, G5 Grills L TR20091050, Rev . A w w w . c a l s p a s . c o m Natural Gas Requirements Always check the r ating plate to make sure the gas supply y ou are hooking up to is the gas type the grill is manuf actured for .
Installation / Assembl y 9 2009 G3, G4, G5 Grills L TR20091050, Rev . A w w w . c a l s p a s . c o m Leak Testing Procedure Perf orm a leak test at least once a year whether the gas supply cylinder has been disconnected or not.
10 Installation / Assembl y 2009 G3, G4, G5 Grills L TR20091050, Rev . A w w w . c a l s p a s . c o m Installing the Grill in a Barbecue Island You will need a second person to help you to avoid damaging the grill or your barbecue island.
Using Y our Grill 11 2009 G3, G4, G5 Grills L TR20091050, Rev . A w w w . c a l s p a s . c o m Read all instructions before you operate your grill. W e recommend y ou wash y our entire grill with soap and water prior to lighting it for the rst time.
12 Using Y our Grill 2009 G3, G4, G5 Grills L TR20091050, Rev . A w w w . c a l s p a s . c o m Basic Grill Operation Before lighting, make sure al l burner controls are off . Do not attempt to light the burners if the smell of gas is present. Check the connection with a soap and water solution after attaching the hose.
Using Y our Grill 13 2009 G3, G4, G5 Grills L TR20091050, Rev . A w w w . c a l s p a s . c o m Electronically Lighting the Grill Open the hood. 1. K eep your face as f ar away fr om the burners as possible. 2. Rapidly rotate the burner knob counter clockwise past the light 3.
14 Using Y our Grill 2009 G3, G4, G5 Grills L TR20091050, Rev . A w w w . c a l s p a s . c o m Manually Lighting the Grill WARNING: Do not use standard matches or cigarette lighters to perform match lighting pr ocedures. Serious burns can occur and lighters can explode.
Cleaning and Maintenance 15 2009 G3, G4, G5 Grills L TR20091050, Rev . A w w w . c a l s p a s . c o m Clean internal parts of the grill regularly as determined by the amount of use and foods cook ed. The entire grill should be cleaned at least once a year .
16 Cleaning and Maintenance 2009 G3, G4, G5 Grills L TR20091050, Rev . A w w w . c a l s p a s . c o m Stainless Steel Do NOT use wire wool pads, scrappers, harsh abrasive, scoring materials, bleaches, or harsh cleaners on your grill, or allow salt and vinegar mixtur es to remain in contact for a long period of time.
Appendix 17 2009 G3, G4, G5 Grills L TR20091050, Rev . A w w w . c a l s p a s . c o m Troubleshooting Problem: Smell of gas is present Solution: Check for loose connections in the gas line. Perform a leak test following the procedure described in this manual.
18 Appendix 2009 G3, G4, G5 Grills L TR20091050, Rev . A w w w . c a l s p a s . c o m Problem: Plugged orice Solution: Unplug the orice as follows: Remov e cooking grills, ame tamer and grease • tray .
Appendix 19 2009 G3, G4, G5 Grills L TR20091050, Rev . A w w w . c a l s p a s . c o m Problem: Yellow Flame Solution: Once the entire burner is operating, check the ame color to be sure that it is mostly blue. Some yellow at the tips may be present due to impurities in the fuel.
20 Appendix 2009 G3, G4, G5 Grills L TR20091050, Rev . A w w w . c a l s p a s . c o m Replacement Covers CVRBL T001 COVER, GRILL, MEDIUM, 3 BURNER CVRBL T003 COVER, GRILL, MEDIUM, 4 BURNER CVRBL T007 COVER, GRILL, MEDIUM, 3 BURNER Removing and Replacing Burners Disconnect or shut off the gas line connect to the grill.
Appendix 21 2009 G3, G4, G5 Grills L TR20091050, Rev . A w w w . c a l s p a s . c o m 2009 Warranty LMS warrants the G3, G4, and G5 grill and associated hardwar e from defects in material and workmanship for a period of one year from the original date of purchase.
22 Appendix 2009 G3, G4, G5 Grills L TR20091050, Rev . A w w w . c a l s p a s . c o m to the original purchase price. W arrant y repair and / or replacement is the sole discretion of LMS and this warr anty does not cover costs therein, including but not limited to: freight, removal, re-installation, etc.
Appendix 23 2009 G3, G4, G5 Grills L TR20091050, Rev . A w w w . c a l s p a s . c o m Disclaimers LMS shall not be liable for loss of use of the barbecue grills or related hardware or other incidenta.
24 Appendix 2009 G3, G4, G5 Grills L TR20091050, Rev . A w w w . c a l s p a s . c o m.
Appendix 25 2009 G3, G4, G5 Grills L TR20091050, Rev . A w w w . c a l s p a s . c o m.
L TR20091050, Rev . A 12/11/08 LMS Customer Service Department 1462 East Ninth Street Pomona, CA 91766 T oll Free: 1-800-CAL -SPAS F ax: 1-909-629-3890 www.
Un point important après l'achat de l'appareil (ou même avant l'achat) est de lire le manuel d'utilisation. Nous devons le faire pour quelques raisons simples:
Si vous n'avez pas encore acheté Cal Flame G4 c'est un bon moment pour vous familiariser avec les données de base sur le produit. Consulter d'abord les pages initiales du manuel d'utilisation, que vous trouverez ci-dessus. Vous devriez y trouver les données techniques les plus importants du Cal Flame G4 - de cette manière, vous pouvez vérifier si l'équipement répond à vos besoins. Explorant les pages suivantes du manuel d'utilisation Cal Flame G4, vous apprendrez toutes les caractéristiques du produit et des informations sur son fonctionnement. Les informations sur le Cal Flame G4 va certainement vous aider à prendre une décision concernant l'achat.
Dans une situation où vous avez déjà le Cal Flame G4, mais vous avez pas encore lu le manuel d'utilisation, vous devez le faire pour les raisons décrites ci-dessus,. Vous saurez alors si vous avez correctement utilisé les fonctions disponibles, et si vous avez commis des erreurs qui peuvent réduire la durée de vie du Cal Flame G4.
Cependant, l'un des rôles les plus importants pour l'utilisateur joués par les manuels d'utilisateur est d'aider à résoudre les problèmes concernant le Cal Flame G4. Presque toujours, vous y trouverez Troubleshooting, soit les pannes et les défaillances les plus fréquentes de l'apparei Cal Flame G4 ainsi que les instructions sur la façon de les résoudre. Même si vous ne parvenez pas à résoudre le problème, le manuel d‘utilisation va vous montrer le chemin d'une nouvelle procédure – le contact avec le centre de service à la clientèle ou le service le plus proche.
