Manuel d'utilisation / d'entretien du produit GENESIS GENESIS 1300 du fabricant Weber
Aller à la page of 32
W E B E R W E B E R GENESIS ® 1300 Natural Gas Barbecue Serial Number Please use this number in registering your w arranty and any correspondence with the f actory . Owner’ s Manual 92726 11/98 ® W ARNING 1. Do not store spare LP Cylinder within 10 feet (3m) of this appliance.
2 D ANGER Failure to f ollo w the Dangers, W arnings and Cautions contained in this Owner’ s Manual may result in serious bodil y injur y or death, or in a fire or an explosion causing damage to property . W ARNINGS Do not store a spare or disconnected LP tank under or near this barbecue.
3 W eber-Stephen Products Co. (W eber) hereby warr ants to the ORIGINAL PURCHASER of this W eber Gas Barbecue that it will be free of def ects in mater ial and workmanship from the date of purchase as.
4 © 1998 W eber . Weber , , Genesis, Fla v orizer and Crossov er are registered U .S. trademarks; P er ma-Mount, Gas Catcher , FlameCheck, Steam-N-Chips , Spider Stopper , and W ar m-Up are U .S. trademarks of W eber-Stephen Products Co ., 200 East Daniels Road, P alatine, IL 60067-6266.
5 Contents WARNINGS ................................................................ 2 W arranty & P atents .................................................. 3-4 General Instructions .................................................... 6 Assembly .
6 General Instructions Y our W eber Gas Barbecue is a por table outdoor cooking appliance. With the W eber Gas Barbecue you can grill, barbecue, roast and bak e with results that are difficult to duplicate with indoor kitchen appliances. The closed lid and Flav or izer Bars produce that "outdoor" fla v or in the food.
7 Step 1 Check pac kage contents Cooking bo x (assembly) Lid (assembly) Hose Bottom tra y T wo cooking grates Control panel Assembl y T ools needed Regular screwdriv er Phillips screwdriv er Hammer 7/.
Left frame Right frame Wheel frame Caster frame T wo frame connectors W ork table Swing table assemb ly Left hand slide bar Axle T wo accessor y trays W ar ming rack W ar m-Up Basket Five long Fla vor.
T wo plastic buttons (actual size) 1/4-20 keps n ut Fifteen 1/4 inch nylon w ashers T wo hair pin cotters T wo wheel hubcaps T wo 10-24 hex n uts T wo 10-24 x 1 3/4 inch machine screws T wo Phillips s.
10 Figure 1 W E B E R W E B E R Figure 2 Leg tabs F rame tabs (a) (b) Right frame Left frame Step 2 Assemble wheels Y ou will need: axle, two wheel hubcaps , two wheels, wheel frame, hammer and a b lock of wood. Place one end of the axle on the bloc k of wood (or other protected surf ace).
11 Figure 3 Dimples to the inside Figure 4 Step 4 Continue frame assemb ly Y ou will need: caster frame, wheel fr ame, f our 1/4-20 x 1/2 inch bolts, f our nylon washers and a 7/16 inch wrench. Place the caster frame onto the tabs of the left frame with the dimple to the inside.
12 Figure 6 View from rear of barbecue Plastic buttons Figure 5 Step 7 Add front panel Y ou will need: front panel and two plastic b uttons. T ur n frame assembly right side up . Align the panel with the holes in the frame and inser t the plastic buttons through the front panel and fr ame .
13 Guide screw (a) (b) (c) Wing nuts View from behind cooking bo x Figure 9 Figure 7 Burner tubes F rame brace (a) (b) Spacer brac ket K eps nut Ta b F rame cross piece Nylon washer Bolt Slide the cooking bo x to the left within the frame. Put the washer on the bolt.
14 Figure 11 Igniter lock n ut K eyhole in frame brace F rame brace Manif old brack et Figure 10 Small par t of keyhole in frame brace F rame brace F rame brace (a) (b) (c) Step 9 Install manif old brack et Y ou will need: manif old brac ket Hook the brac ket onto the manif old at the center burner valv e.
15 15 T ypical natural gas supply installation. Figure 12. Gas line piping ■ If the length of line required does not e xceed 50 f eet, use a 5/8" O .D . tube. One size larger should be used f or lengths greater than 50 f eet. ■ Gas piping ma y be copper tubing, type K or L; polyeth ylene plastic tube, with a minimum w all thickness of .
16 Figure 13 Figure 14 (a) Step 12 Check that all b ur ner valv es are off Y ou will need: one burner control knob . V alves are shipped in the OFF position, b ut you should check to be sure . Put the knob on each v alv e. Chec k by pushing down and turning clockwise.
17 (a) Figure 16 (c) (b) Figure 15 Male fitting T o barbecue Quick disconnect engaged Collar Locking shut off Outside house wall (a) (b) Step 14 Check f or gas leaks D ANGER Do not use an open flame to chec k for gas leaks. Be sure there are no sparks or open flames in the area while y ou chec k for leaks.
18 Figure 20 Figure 19 Figure 21 Bottom tra y Finger grip on front edge of bottom tra y Finger grip F ront side of catch pan holder Figure 17 Figure 18 Step 15 Install Flav orizer Bars and Cooking Grates Y ou will need: five long Fla vorizer Bars, eight short Flav or izer Bars and two cooking g rates.
19 Hair pin cotter Hinge pin Figure 22 Step 18 Add tool holders, control panel and b ur ner control knobs Y ou will need: three tool holders, control panel, two Phillips screws/w ashers, a Phillips scre wdr iver , and three bur ner control knobs. Hook the tool holders ov er the frame rail.
20 Slot in frame (view from belo w) Inser t one end of the hinge rod into the hole in the frame. Figure 25 (a). Inser t the other end into the hole in the swing tab le end brac ket. Figure 25 (b). Hold the end br ack et at an angle so the lower tab is inside the fr ame tube.
21 Step 20 Complete accessor y installation Y ou will need: W ar m-Up Basket, war ming rack, work table , accessor y rack, three tubing plugs , ther mometer and a hammer . Inser t one end of the Weber W ar m-Up Basket into the hole in the right end of the lid and the other end into the slot in the left end of the lid.
22 5 7 4 6 3 2 1 Figure 1 Crosso ver Ignition System OPERA TING INSTR UCTIONS Lighting Summar y lighting instructions are on the control panel. 1) Open the lid. Figure 1. 2) Make sure all burner control knobs are tur ned OFF . (Push each burner control knob down and turn clockwise .
23 7 5 4 3 2 1 6 Figure 2 Manual Lighting Manual Lighting W ARNING: Do not lean over open barbecue. Keep your face and bod y at least one foot awa y fr om the matchlight hole when lighting the barbecue. 5) Push Front b ur ner control knob down and tur n to ST ART / HI.
24 Cooking W ARNING: Do not move the W eber Gas Barbecue when operating or hot. Y ou can adjust the FRONT , CENTER and BACK b ur ners as desired. The control settings High (H), Medium (M), Low (L), or Off (O) are described in your W eber cookbook.
25 Figure 3 (b) (c) (a) Annual Maintenance After a period of nonuse we recommend that you perf or m the f ollowing maintenance procedures f or y our safety . W ARNING: Check hose bef ore eac h use of barbecue for nic ks, cracking, abrasions or cuts.
26 Burner inside cooking bo x Figure 6 Dark blue Light blue Tips occasionally yello wish Figure 4 V entur i Air shutter V entur i fin W eber Spider Stopper Guard Figure 5 Flames Figure 7 Figure 8 Gene.
Figure 11 27 View from behind cooking bo x Wing nuts Figure 10 Guide screw Crossov er tube Figure 12 Figure 9 e) Remov e the manifold brac ket and unscrew the tw o wing nuts that hold the manif old to the cooking box. Pull the manif old and v alve assemb ly out of the burners and carefully set it down.
28 Figure 15 White wire Black wire ■ Check that the Crosso v er Ignition button pushes the igniter (button) do wn, and returns to the up position. ■ Check to see if the igniter is loose in the fr ame. Tighten if necessar y; see Step “Install igniter” f or correct procedure.
Prob lem Burners b urn with a yello w or orange flame, in conjunction with the smell of gas. Burner does not light, or flame is low in HIGH position. Experiencing flare-ups: C A UTION : Do not line the bottom tray with aluminum f oil. Burner flame pattern is erratic.
30 W E B E R W E B E R 6 1 2 3 4 5 9 10 11 14 12 13 17-18 25 26 19 46 38 47 44 42 41 40 39 38 36 35 34 33 32 31 30 45 43 27 28 29 37 15 16 20 21 24 8 7 23 13, 18 55 54 53 52 50-51 49 48 22 ® ® ® ®.
31 1 Hair pin cotters (2) 2 Hinge pins (2) 3 Right endcap 4 Shroud assembly 5 Lid handle 6 W ar m-Up Basket 7 W ar ming rack 8 Shor t Flav orizer bars (8) 9 Long Flav or izer bars (5) 10 Cooking grate.
A F INAL W ORD OF T HANKS hank you for choosing a W eber Barbecue. Our family her e at W eber has worked har d to produce the highest quality products for your satisfaction. While we give much attention to our products, an occasional error may occur .
Un point important après l'achat de l'appareil (ou même avant l'achat) est de lire le manuel d'utilisation. Nous devons le faire pour quelques raisons simples:
Si vous n'avez pas encore acheté Weber GENESIS GENESIS 1300 c'est un bon moment pour vous familiariser avec les données de base sur le produit. Consulter d'abord les pages initiales du manuel d'utilisation, que vous trouverez ci-dessus. Vous devriez y trouver les données techniques les plus importants du Weber GENESIS GENESIS 1300 - de cette manière, vous pouvez vérifier si l'équipement répond à vos besoins. Explorant les pages suivantes du manuel d'utilisation Weber GENESIS GENESIS 1300, vous apprendrez toutes les caractéristiques du produit et des informations sur son fonctionnement. Les informations sur le Weber GENESIS GENESIS 1300 va certainement vous aider à prendre une décision concernant l'achat.
Dans une situation où vous avez déjà le Weber GENESIS GENESIS 1300, mais vous avez pas encore lu le manuel d'utilisation, vous devez le faire pour les raisons décrites ci-dessus,. Vous saurez alors si vous avez correctement utilisé les fonctions disponibles, et si vous avez commis des erreurs qui peuvent réduire la durée de vie du Weber GENESIS GENESIS 1300.
Cependant, l'un des rôles les plus importants pour l'utilisateur joués par les manuels d'utilisateur est d'aider à résoudre les problèmes concernant le Weber GENESIS GENESIS 1300. Presque toujours, vous y trouverez Troubleshooting, soit les pannes et les défaillances les plus fréquentes de l'apparei Weber GENESIS GENESIS 1300 ainsi que les instructions sur la façon de les résoudre. Même si vous ne parvenez pas à résoudre le problème, le manuel d‘utilisation va vous montrer le chemin d'une nouvelle procédure – le contact avec le centre de service à la clientèle ou le service le plus proche.
