Manuel d'utilisation / d'entretien du produit SV620 du fabricant Kohler
Aller à la page of 16
O WNER ' S M ANUAL V ERTICAL C RANKSHAFT COURAGE SV470-SV620.
2 Safety Precautions T o ensure safe operation please read the following statements and understand their meaning. Also refer to your equipment owner's manual for other important safety information. This manual contains safety precautions which are explained below .
3 Safety Precautions (Cont.) Lethal Exhaust Gases! Engine exhaust gases contain poisonous carbon monoxide. Carbon monoxide is odorless, colorless, and can cause death if inhaled. Avoid inhaling exhaust fumes, and never run the engine in a closed building or confined area.
4 Figure 1. T ypical COURAGE ® Series V ertical Shaf t Engine. Oil Recommendations Using the proper type and weight of oil in the crankcase is extremely important. So is checking oil daily and changing oil regularly . Failure to use the correct oil, or using dirty oil, causes premature engine wear and failure.
5 Fuel T ype For best results use only clean, fresh, unleaded gasoline with a pump sticker octane rating of 87 or higher . In countries using the Research method, it should be 90 octane minimum. Unleaded gasoline is recommended as it leaves less combustion chamber deposits.
6 Pre-Start Checklist • Check oil level. Add oil if low . Do not overfill. • Check fuel level. Add fuel if low . • Check cooling air intake areas and external surfaces of engine.
7 b. For engines equipped with a shutdown solenoid: Position the throttle control between half and full throttle; then stop the engine. Battery A 12 volt battery is normally used. Refer to the operating instructions of the equipment this engine powers, for specific battery requirements.
8 Maintenance Instructions Maintenance, repair , or replacement of the emission control devices and systems, which are being done at the customers expense, may be performed by any non-road engine repair establishment or individual. W arranty repairs must be performed by an authorized Kohler service outlet.
9 Figure 7. Oil Level Dipstick. 5. If the level is low , add oil of the proper type, up to the “F” mark on the dipstick. (Refer to Oil T ype on page 4.) Always check the level with the dipstick before adding more oil. N OT E : T o prevent extensive engine wear or damage, always maintain the proper oil level in the crankcase.
10 Service Precleaner and Air Cleaner Element This engine is equipped with a replaceable, high density paper air cleaner element. Some engines are also equipped with an oiled, foam precleaner , located in the outer air cleaner cover . See Figure 9. Check the air cleaner daily or before starting the engine .
11 Figure 1 1. Inst alling Air Cleaner Element. Clean Air Intake/Cooling Areas T o ensure proper cooling, make sure the grass screen, cooling fins, and other external surfaces of the engine are kept clean at all times .
12 Fuel Filter Some engines are equipped with an in-line fuel filter . P eriodically inspect the filter and replace when dirty . Replacement is recommended annually or every 100 hours .
13 2. Low Idle Fuel Needle Setting: Place the throttle into the idle or slow position. T urn the low idle fuel adjusting needle out (counterclockwise) from the preliminary setting until engine speed decreases (rich). Note the position of the needle. Now turn the adjusting needle in (clockwise).
14 Parts Ordering The engine Model, Specification, and Serial Numbers are required when ordering replacement parts from your Kohler Engine Service Dealer . These numbers are found on the identification plate which is affixed to the engine shrouding. Include letter suffixes if there are any .
15 Continued on next page. KOHLER CO. FEDERAL AND CALIFORNIA EMISSION CONTROL SYSTEMS LIMITED W ARRANTY SMALL OFF-ROAD ENGINES The U.S. Environmental Protection Agency (EP A), the California Air Resources Board (CARB), and Kohler Co.
Listed below are the parts covered by the Federal and California Emission Control Systems W arranty . Some parts listed below may require scheduled maintenance and are warranted up to the first scheduled replacement point for that part.
Un point important après l'achat de l'appareil (ou même avant l'achat) est de lire le manuel d'utilisation. Nous devons le faire pour quelques raisons simples:
Si vous n'avez pas encore acheté Kohler SV620 c'est un bon moment pour vous familiariser avec les données de base sur le produit. Consulter d'abord les pages initiales du manuel d'utilisation, que vous trouverez ci-dessus. Vous devriez y trouver les données techniques les plus importants du Kohler SV620 - de cette manière, vous pouvez vérifier si l'équipement répond à vos besoins. Explorant les pages suivantes du manuel d'utilisation Kohler SV620, vous apprendrez toutes les caractéristiques du produit et des informations sur son fonctionnement. Les informations sur le Kohler SV620 va certainement vous aider à prendre une décision concernant l'achat.
Dans une situation où vous avez déjà le Kohler SV620, mais vous avez pas encore lu le manuel d'utilisation, vous devez le faire pour les raisons décrites ci-dessus,. Vous saurez alors si vous avez correctement utilisé les fonctions disponibles, et si vous avez commis des erreurs qui peuvent réduire la durée de vie du Kohler SV620.
Cependant, l'un des rôles les plus importants pour l'utilisateur joués par les manuels d'utilisateur est d'aider à résoudre les problèmes concernant le Kohler SV620. Presque toujours, vous y trouverez Troubleshooting, soit les pannes et les défaillances les plus fréquentes de l'apparei Kohler SV620 ainsi que les instructions sur la façon de les résoudre. Même si vous ne parvenez pas à résoudre le problème, le manuel d‘utilisation va vous montrer le chemin d'une nouvelle procédure – le contact avec le centre de service à la clientèle ou le service le plus proche.
