Manuel d'utilisation / d'entretien du produit BCDV36 du fabricant Heatiator
Aller à la page of 28
01-03 1 33606 Rev D INST ALLA TION & OPERA TING INSTRUCTIONS BCDV36 BUILDERS CHOICE DIRECT VENT DECORA TIVE GAS APPLIANCE WARNING! Improper installation, adjustment, alteration, service or maintenance can cause injury or property damage. Refer to this manual.
33606 Rev D 2 01-03 BUILDER'S CHOICE SERIES INST ALLA TION INSTRUCTIONS CONTENTS A . Appliance S pecifications ..................................................................................................... ............................ 3 B .
01-03 3 33606 Rev D BUILDER'S CHOICE SERIES INST ALLA TION INSTRUCTIONS A. APPLIANCE SPECIFICA TIONS 1. U.S. AND CANADA CERTIFICA TION The Builder's Choice Series Gas Appliance has been tested in accordance with the ANSI st andard Z21.50b-1998 and U.
33606 Rev D 4 01-03 BUILDER'S CHOICE SERIES INST ALLA TION INSTRUCTIONS TYPICAL HORIZONT AL INST ALLA TION TYPICAL VERTICAL INST ALLA TION.
01-03 5 33606 Rev D BUILDER'S CHOICE SERIES INST ALLA TION INSTRUCTIONS B. NOMENCLA TURE # g o l a t a Cn o i t p i r c s e D e c i o h C s r e d l i u B - V D C B ) x i f f u s o n ( V D C Bs a .
33606 Rev D 6 01-03 BUILDER'S CHOICE SERIES INST ALLA TION INSTRUCTIONS C. LOCA TION AND CLEARANCES 1. APPLIANCE LOCA TIONS AND SP ACE REQUIREMENTS Figure 1 illustrates a variety of ways the appliance may be located in a room. The Builder's Choice Series may be installed directly on the floor or on a hearth.
01-03 7 33606 Rev D BUILDER'S CHOICE SERIES INST ALLA TION INSTRUCTIONS D. FRAMING Figure 3 shows a typical framing of this appliance using combustible materials. Figure 4 shows the mantel heights for mantel projections. All required clearances to combustibles must be adhered to.
33606 Rev D 8 01-03 BUILDER'S CHOICE SERIES INST ALLA TION INSTRUCTIONS F . VENTING WARNING - RISK OF FIRE! Air space clearances must be maintained at all times. WARNING - RISK OF FIRE! The horizontal run of vent must have a 1/4 rise for every 1 ft.
01-03 9 33606 Rev D BUILDER'S CHOICE SERIES INST ALLA TION INSTRUCTIONS c. No Elbows The maximum horizontal run with no vertical sections of vent is 18 from the back of the appliance to the base of the cap. See Figure 7. d . A 45° Elbow For corner venting, a maximum of one 45° elbow may be used.
33606 Rev D 10 01-03 BUILDER'S CHOICE SERIES INST ALLA TION INSTRUCTIONS Figure 1 1 - T ermination Cap Locations DIMENSION DESCRIPTIONS A Clearance above the ground, a veranda, porch, deck or bal- cony - 12 inches (30 cm) minimum.
01-03 11 33606 Rev D BUILDER'S CHOICE SERIES INST ALLA TION INSTRUCTIONS 2. VERTICAL TERMINA TION a. Clearances See Figure 13 for clearance information. b . V ent Lengths V arious venting configurations are shown in Figures14 and 15 from which the maximum vent runs can be determined.
33606 Rev D 12 01-03 BUILDER'S CHOICE SERIES INST ALLA TION INSTRUCTIONS c. Firestop Spacer/Chimney Installation Frame an opening and install an FS6 Firestop S pacer whenever the vent penetrates a ceiling/ floor area, as shown in Figure 16. Frame the opening with the same sized lumber as used in the ceiling/floor joists.
01-03 13 33606 Rev D BUILDER'S CHOICE SERIES INST ALLA TION INSTRUCTIONS 1. ATT ACHING THE VENTING TO THE APPLIANCE T o attach the first VP section to the appliance collars, simply slide the flared end of the inner vent of the VP section over the inner collar on the appliance.
33606 Rev D 14 01-03 BUILDER'S CHOICE SERIES INST ALLA TION INSTRUCTIONS 4. ASSEMBLING SLIP SECTIONS Slip sections should be snapped into the first mating piece, then expanded to their desired length, making sure that a 1.5 overlap is maintained between the two sections of the slip section.
01-03 15 33606 Rev D BUILDER'S CHOICE SERIES INST ALLA TION INSTRUCTIONS H. UTILITIES 1. GAS LINE CONNECTION Open the control access panel as shown in Figure 24. See Figure 25 to connect the gas line properly . All connections must be checked for leaks with a soap and water solution or a leak detector .
33606 Rev D 16 01-03 BUILDER'S CHOICE SERIES INST ALLA TION INSTRUCTIONS Figure 27 Standing Pilot Ignition Wiring Diagram 14-3 with Ground Romex is the recommended wiring to the appliance Junction Box. Detailed picture of the Junc- tion Box (Optional for Stand- ing Pilot Appliances).
01-03 17 33606 Rev D BUILDER'S CHOICE SERIES INST ALLA TION INSTRUCTIONS I. FINISHING 1. COMBUSTIBLE FINISHING MA TERIAL Materials made of or surfaced with wood, compressed paper , plant fibers, .
33606 Rev D 18 01-03 BUILDER'S CHOICE SERIES INST ALLA TION INSTRUCTIONS J. APPLIANCE PREP ARA TION 1. LOG SET The log set should look similar to that in Figure30.
01-03 19 33606 Rev D BUILDER'S CHOICE SERIES INST ALLA TION INSTRUCTIONS 1. Turn off all wall switches to the appliance or remote. 2. Open the control access panel. 3 Turn gas line to CLOSED. Wait 5 minutes to clear out any gas. Then smell for gas, including near the floor .
33606 Rev D 20 01-03 BUILDER'S CHOICE SERIES INST ALLA TION INSTRUCTIONS WARNING! Children and adults should be alerted to the hazards of high surface temperatures and should stay away to avoid burns or clothing ignition. Y oung children should be carefully supervised when they are in the same room as the appliance.
01-03 21 33606 Rev D BUILDER'S CHOICE SERIES INST ALLA TION INSTRUCTIONS M. FUEL CONVERSION Do not burn wood or other material in this appliance. Natural or propane gas conversions necessary to meet the application need to be made by a qualified technician using Hearth & Home T echnologies specified and approved parts.
33606 Rev D 22 01-03 BUILDER'S CHOICE SERIES INST ALLA TION INSTRUCTIONS 5. LOG REMOV AL/REPLACEMENT If removal of the logs becomes necessary , remove the two screws at each side of the front log. Grasp the front log. Pull the log toward the front and up, off the burner .
01-03 23 33606 Rev D BUILDER'S CHOICE SERIES INST ALLA TION INSTRUCTIONS P . OPTIONAL COMPONENTS Contact your local Heatilator Dealer by calling: 1-800-843-2848.
33606 Rev D 24 01-03 BUILDER'S CHOICE SERIES INST ALLA TION INSTRUCTIONS Q. REPLACEMENT PARTS Replacement p arts are available from your distributor/dealer .
01-03 25 33606 Rev D BUILDER'S CHOICE SERIES INST ALLA TION INSTRUCTIONS HOMEOWNERS NOTES.
33606 Rev D 26 01-03 BUILDER'S CHOICE SERIES INST ALLA TION INSTRUCTIONS HOMEOWNERS NOTES.
01-03 27 33606 Rev D BUILDER'S CHOICE SERIES INST ALLA TION INSTRUCTIONS Index A Access Panel 15 Air Shutter Adjustment 20 Appliance Preparation 18 B Bathtub Areas 3 BC10 23 BTUs 15 Building Code.
30532 Rev D 28 01-03 Gas Appliance (Fireplace) Limited Lifetime W arranty HEARTH & HOME TECHNOLOGIES (HHT) extends the following warranty for HEA TILA TOR â gas appliances installed in the United S tates of America or Canada (the Appliance).
Un point important après l'achat de l'appareil (ou même avant l'achat) est de lire le manuel d'utilisation. Nous devons le faire pour quelques raisons simples:
Si vous n'avez pas encore acheté Heatiator BCDV36 c'est un bon moment pour vous familiariser avec les données de base sur le produit. Consulter d'abord les pages initiales du manuel d'utilisation, que vous trouverez ci-dessus. Vous devriez y trouver les données techniques les plus importants du Heatiator BCDV36 - de cette manière, vous pouvez vérifier si l'équipement répond à vos besoins. Explorant les pages suivantes du manuel d'utilisation Heatiator BCDV36, vous apprendrez toutes les caractéristiques du produit et des informations sur son fonctionnement. Les informations sur le Heatiator BCDV36 va certainement vous aider à prendre une décision concernant l'achat.
Dans une situation où vous avez déjà le Heatiator BCDV36, mais vous avez pas encore lu le manuel d'utilisation, vous devez le faire pour les raisons décrites ci-dessus,. Vous saurez alors si vous avez correctement utilisé les fonctions disponibles, et si vous avez commis des erreurs qui peuvent réduire la durée de vie du Heatiator BCDV36.
Cependant, l'un des rôles les plus importants pour l'utilisateur joués par les manuels d'utilisateur est d'aider à résoudre les problèmes concernant le Heatiator BCDV36. Presque toujours, vous y trouverez Troubleshooting, soit les pannes et les défaillances les plus fréquentes de l'apparei Heatiator BCDV36 ainsi que les instructions sur la façon de les résoudre. Même si vous ne parvenez pas à résoudre le problème, le manuel d‘utilisation va vous montrer le chemin d'une nouvelle procédure – le contact avec le centre de service à la clientèle ou le service le plus proche.
