Manuel d'utilisation / d'entretien du produit 463666508 du fabricant Char-Broil
Aller à la page of 28
THIS GRILL IS FOR OUTDOOR USE ONL Y . If you have any questions or need assistance during assembly , please call 1-800-241-7548. T o insure your satisfaction and for follow-up service, register your grill online at www.
2 • 463666508 1. Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance. 2. An LP cylinder not connected for use shall not be stored in the vicinity of this or any other appliance. WARNING CA UTION For residential use only.
T ABLE OF CONTENTS F o r Y o u r S a f e t y ......................................2 G r i l l S e r v i c e C e n t e r ...................................2 P r o d u c t R e c o r d I n f o r m a t i o n ............................2 Installation Safety Precautions .
• NEVER store a spare LP cylinder under or near the appliance or in an enclosed area. • Never fill a cylinder beyond 80% full. • An over filled or improperly stored cylinder is a hazard due to possible gas release from the safety relief valve. This could cause an intense fire with risk of property damage, serious injury or death.
WARNING If “growing” bubbles appear do not use or move the LP cylinder . Contact an LP gas supplier or your fire department! Connecting Regulator to the LP Cylinder 1. LP cylinder must be properly secured onto grill. (Refer to assembly section.) 2.
6. T urn the coupling nut clockwise and tighten to a full stop. The regulator will seal on the back-check feature in the LP cylinder valve, resulting in some resistance. An additional one-half to three-quarters turn is required to complete the connection.
For Safe Use of Your Grill and to Avoid Serious Injury: • Do not let children operate or play near grill. • Keep grill area clear and free from materials that burn. • Do not block holes in sides or back of grill. • Check burner flames regularly .
CA UTION If ignition does NOT occur in 5 seconds, turn the burner controls OFF, wait 5 minutes and repeat the lighting procedure. If the burner does not ignite with the valve open, gas will continue to flow out of the burner and could accidently ignite with risk of injury.
Cleaning the Burner Assembly Follow these instructions to clean and/or replace parts of burner assembly or if you have trouble igniting grill. 1. Turn gas off at control knobs and LP cylinder. 2. vaporiser b 3. 4. 5. 6. 7. 8. VERY IMPORTANT: Burner tubes must reengage valve openings.
Food Safety Food safety is a very important part of enjoying the outdoor cooking experience. T o keep food safe from harmful bacteria, follow these four basic steps: Clean: W ash hands, utensils, and surfaces with hot soapy water before and after handling raw meat and poultry .
463666508 • 1 1 P ARTS LIST – Model No. 463666508 Key Qty Description Part # A 1 Firebox Assembly . . . . . . . . . . . . . . . . . 80013174 B 1 V alve/Hose/Regulator. . . . . . . . . . . . . . 80013175 C 1 Control Panel . . . . . . . . . . . . . .
12 • 463666508 P ARTS DIAGRAM – Model No. 463666508 A CC CC B C D E F G G H H I I J J K K L L M M N O O P Q R S DD DD T U W X Y Z AA V AA BB FF EE GG GG.
463666508 • 13 2 ASSEMBL Y – Model No. 463666508 1 T urn assembly over and attach back support brace to legs and side support braces using four 1/4-20x2” carriage bolts and four 1/4-20 tee knobs (A).
14 • 463666508 3 4 T urn assembly upside-down. Insert axle bolts into wheels. position tank support bracket between left legs. Insert axle bolt through leg and bracket and secure with hitch pin . Facing the back, 5/16” Axle Bolt Qty. 2 1” Hitch Pin Qty.
5 Place cart in the upright position. Place firebox assembly onto cart, making sure that regulator hose hangs inside cart and control panel overlaps front panel. Secure firebox to cart using four #10-24x1¼” carriage bolts, fiber washers and #10-24 wing nuts.
7 1/4-20 Tee Knob Qty. 8 1/4-20x2” Carriage Bolt Qty. 8 Push Fastener Qty. 4 Slide shelf arms into leg assemblies and secure with one push fastener per arm.
1/4-20x1/2” Machine Screw Qty. 4 Fiber Washer Qty. 6 #10-24 Wing Nut Qty. 2 Attach handle to front of lid using two insulation washers , fiber washers and #10-24 wing nuts . Attach upper lid hinges to back of lid using two 1/4-20x1/2” machine screws , fiber washers , and 1/4-20 flange nuts per hinge.
11 Place vaporiser bar onto V -shaped bar rests inside firebox. Place cooking grate onto firebox. Cooking grate 80012776 Vaporiser bar 80012775 NOTE: The vaporiser bar must be inserted into firebox at an angle in order to fit beneath cooking grate supports.
13 Hang grease clip from bottom of firebox and place grease cup into grease clip. Grease clip 80000271 CA UTION Failure to install grease clip and cup will cause hot grease to drip from bottom of grill with risk of fire or property damage.
15 LP CYLINDER IS SOLD SEPARATELY. Fill and leak check the cylinder before attaching to grill and regulator (see Use & Care section). Once cylinder has been filled and leak checked, place cylinder into notches in tank support bracket. Make sure cylinder valve is facing front of grill.
LIMITED W ARRANTY Manufacturer warrants to the original consumer-purchaser only that this product shall be free from defects in workmanship and materials after correct assembly and under normal and reasonable home use for the periods indicated below beginning on the date of purchase.
EMERGENCIES: If a gas leak cannot be stopped, or a fire occurs due to gas leakage, call the fire department. Emergencies Problem Gas leaking from cracked/cut/burned hose. Gas leaking from LP cylinder . Gas leaking from LP cylinder valve. Gas leaking between LP cylinder and regulator connection.
Troubleshooting ( continued ) Problem Burner(s) will not light using ignitor . Burner(s) will not match light. Low flame, drop in gas flow . Flames blow out. Flare-up. Persistent grease fire. Flashback... (fire in burner tube(s)). Unable to fill LP cylinder .
Please register your grill online at: (If you register online, you do not need to send in this registration card.) WWW .GRILLREGISTRA TION.COM Chimenea / Envíelo a: La parrilla estaba ensamblada 24 .
This page intentionally blank 463666508 • 25.
This page intentionally blank 26 • 463666508.
This page intentionally blank 463666508 • 27.
Char-Broil, LLC Printed in China • 2007 Columbus, GA 31902 • ST OP Should you encounter a problem with our product CALL US FIRST Do not return this product to the store. WE CAN HELP GRILL SERVICE CENTER 1-800-241-7548 HOURS 8AM-6PM EST Mon-Fri Please ensure your warranty registration is complete.
Un point important après l'achat de l'appareil (ou même avant l'achat) est de lire le manuel d'utilisation. Nous devons le faire pour quelques raisons simples:
Si vous n'avez pas encore acheté Char-Broil 463666508 c'est un bon moment pour vous familiariser avec les données de base sur le produit. Consulter d'abord les pages initiales du manuel d'utilisation, que vous trouverez ci-dessus. Vous devriez y trouver les données techniques les plus importants du Char-Broil 463666508 - de cette manière, vous pouvez vérifier si l'équipement répond à vos besoins. Explorant les pages suivantes du manuel d'utilisation Char-Broil 463666508, vous apprendrez toutes les caractéristiques du produit et des informations sur son fonctionnement. Les informations sur le Char-Broil 463666508 va certainement vous aider à prendre une décision concernant l'achat.
Dans une situation où vous avez déjà le Char-Broil 463666508, mais vous avez pas encore lu le manuel d'utilisation, vous devez le faire pour les raisons décrites ci-dessus,. Vous saurez alors si vous avez correctement utilisé les fonctions disponibles, et si vous avez commis des erreurs qui peuvent réduire la durée de vie du Char-Broil 463666508.
Cependant, l'un des rôles les plus importants pour l'utilisateur joués par les manuels d'utilisateur est d'aider à résoudre les problèmes concernant le Char-Broil 463666508. Presque toujours, vous y trouverez Troubleshooting, soit les pannes et les défaillances les plus fréquentes de l'apparei Char-Broil 463666508 ainsi que les instructions sur la façon de les résoudre. Même si vous ne parvenez pas à résoudre le problème, le manuel d‘utilisation va vous montrer le chemin d'une nouvelle procédure – le contact avec le centre de service à la clientèle ou le service le plus proche.
